MONACO COACH CORPORATION: Safety Recalls in 2005
Updated on March 19, 2026.
There were 8 safety recalls made by MONACO COACH CORPORATION in 2005. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
December 19, 2005
(Campaign #: R05020)
DRIVELINE STRAPS
ON CERTAIN CLASS A MOTOR HOMES BUILT WITH CUMMINS ISX 600 HP ENGINES, THE STRAPS THAT HOLD THE U-JOINTS ONTO THE REAR END AND THE TRANSMISSION CAN LOOSEN. THE LOCK WASHER ON THE STRAPS CAN SPREAD OUT AND ALLOW THE MOUNTING BOLTS TO WORK LOOSE. THIS CAN ALLOW THE DRIVELINE TO SEPARATE FROM THE TRANSMISSION AND FALL OFF THE MOTOR HOME.
NHTSA ID: 05V568000
Component: POWER TRAIN
# of Units Affected: 30
Consequence Summary:
LOSS OF CONTROL OF THE VEHICLE MAY OCCUR, WHICH COULD RESULT IN A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE U-JOINT STRAPS, BOLTS, AND LOCK WASHERS WITH NEW STRAPS, AND BOLTS WITH LOCKTITE FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 28, 2005. OWNERS MAY CONTACT MONACO AT 800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
September 21, 2005
(Campaign #: R05009)
RIM/TREDIT
ON CERTAIN TRAVEL TRAILERS AND FIFTH WHEEL TRAILERS EQUIPPED WITH TREDIT WHEELS, THE RIMS MAY HAVE POOR WELD QUALITY AND INSUFFICIENT PRESS FIT BETWEEN THE WHEEL RIM AND DISC.
NHTSA ID: 05V418000
Component: WHEELS
# of Units Affected: 306
Consequence Summary:
THE CENTER OF THE WHEEL COULD SEPARATE FROM THE RIM. THE WHEEL MAY WOBBLE AND CAUSE A VIBRATION OR THE MOUNTED TIRE COULD LOSE AIR CAUSING THE TIRE TO GO FLAT, RESULTING IN A LOSS OF CONTROL OF THE VEHICLE AND INCREASING THE RISK OF A CRASH.
Corrective Action:
MONACO IS WORKING WITH TREDIT TIRE TO NOTIFY OWNERS AND HAVE THE WHEELS REPLACED FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 26, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
August 24, 2005
(Campaign #: 505011)
HEADLIGHT SWITCH OVERLOADING
ON CERTAIN MOTOR HOMES, THE HEADLIGHT SWITCH IN THE FRONT ELECTRICAL BOX/FIREWALL CAN OVERLOAD.
NHTSA ID: 05V366000
Component: EXTERIOR LIGHTING
# of Units Affected: 451
Consequence Summary:
CHANGES IN THE COMPONENT SUPPLIER RELAY REQUIREMENTS WITH AN UPDATED CONTROLLER WERE CAUSING THE HEADLIGHTS TO STOP FUNCTIONING WITHOUT WARNING. THIS COULD POTENTIALLY CAUSE A CRASH WHILE DRIVING AT NIGHT.
Corrective Action:
DEALERS WILL INSTALL A NEW WIRING HARNESS. THE RECALL BEGAN ON SEPTEMBER 30, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
August 17, 2005
(Campaign #: NR (Not Reported))
ENGINE TURBOCHARGER/SERIES 40/DETROIT DIESEL
ON MOTOR HOMES BUILT ON SPARTAN CHASSIS AND EQUIPPED WITH DETROIT DIESEL SERIES 40 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO SPILL ONTO THE ENGINE.
NHTSA ID: 05V362000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 21
Consequence Summary:
THIS CAN RESULT IN A FIRE IN THE ENGINE COMPARTMENT.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE TURBOCHARGER TO PREVENT THE POSSIBILITY OF AN ENGINE COMPARTMENT FIRE. SPARTAN CHASSIS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT SPARTAN CHASSIS AT 517-543-6400 OR MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
June 21, 2005
(Campaign #: R05008)
FMVSS 121/AIR BRAKE SYSTEMS
CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, 'AIR BRAKE SYSTEMS.' TWO DELIVERY LINES ON THE BRAKE SYSTEM WERE INSTALLED INCORRECTLY.
NHTSA ID: 05V291000
Component: SERVICE BRAKES, AIR
# of Units Affected: 647
Consequence Summary:
THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Corrective Action:
DEALERS WILL SWITCH THE PORT HOOK-UPS OF THE TWO DELIVERY LINES ON THE AIR BRAKE SYSTEM. THE RECALL BEGAN ON AUGUST 30, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
May 13, 2005
(Campaign #: NR (Not Reported))
BURNER TUBES /VEHICLE SYSTEMS/WEBASTO
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
NHTSA ID: 05V223000
Component: EQUIPMENT
# of Units Affected: 1,606
Consequence Summary:
THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.
Corrective Action:
DEALERS WILL REPLACE THE COMBUSTION CHAMBERS (BURNER TUBES) WITH A NEW ONE FREE OF CHARGE. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
March 1, 2005
(Campaign #: R04064)
BATTERY CABLE
ON CERTAIN CLASS A MOTOR HOMES BUILT ON WORKHORSE CHASSIS,THE BATTERY CABLES MAY NOT BE SECURED PROPERLY INSIDE OF THE CHASSIS' FRAME RAIL. THE BATTERY CABLES MAY BE LOCATED TOO NEAR THE ENGINE EXHAUST.
NHTSA ID: 05V081000
Component: ELECTRICAL SYSTEM
# of Units Affected: 81
Consequence Summary:
THIS COULD POTENTIALLY MELT THE BATTERY CABLE AND CAUSE A BACK FEED THROUGH THE CHASSIS 12V SYSTEM WHICH COULD RESULT IN INJURY OR LOSS.
Corrective Action:
DEALERS WILL INSPECT THE BATTERY CABLE TO SEE IF THE CABLE IS PROPERLY MOUNTED INSIDE OF THE CHASSIS FRAME RAIL. IF NECESSARY, THE BATTERY CABLE WILL BE MOUNTED SECURELY IN EXISTING HOLES IN FRAME RAIL FREE OF CHARGE. THE RECALL BEGAN ON MARCH 18, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
February 14, 2005
(Campaign #: R04062)
TRAILING ARMS/SUSPENSION
ON CERTAIN CLASS A MOTOR HOMES, THE SPACER PLATE UNDER THE TRAILING ARMS HAD A TRANSVERSE WELD WHICH CREATES A HEAT RISER AND CAUSE THE TRAILING ARMS TO CRACK.
NHTSA ID: 05V053000
Component: SUSPENSION
# of Units Affected: 2,827
Consequence Summary:
THIS COULD CREATE ROUGH DRIVING CONDITIONS AND DAMAGE TO REAR SUSPENSION SYSTEM. THE DRIVER COULD LOOSE CONTROL OF THE MOTORHOME AND A CRASH COULD OCCUR WITHOUT PRIOR NOTICE.
Corrective Action:
DEALERS WILL INSPECT THE REPLACE THE TRAILING ARMS FOR CRACKS AND REPLACING THE TRAILING ARMS AND U-BOLTS IN THE REAR SUSPENSION OF THE MOTORHOMES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 29, 2005. OWNERS MAY CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.