MONACO COACH CORPORATION: Safety Recalls in 2002
Updated on March 19, 2026.
There were 6 safety recalls made by MONACO COACH CORPORATION in 2002. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
October 22, 2002
(Campaign #: R02175)
MONACO/BOSCH/BRAKE ASSEMBLIES
ON CERTAIN MOTOR HOMES, THE BRAKE ASSEMBLIES EXHIBIT ELEVATED TEMPERATURES THAT CAN LEAD TO CATASTROPHIC DETERIORATION OF THE WHEEL END COMPONENTS SUCH AS BEARINGS, RACES, SPINDLES, KNUCKLES, SEALS, HUBS, ROTORS, PATCH BOLTS, CALIPERS, BRAKE PADS, AND ABS SENSORS.
NHTSA ID: 02V278000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 8,581
Consequence Summary:
THIS COULD RESULT IN LOSS OF CONTROL, AND/OR THE POTENTIAL FOR A FIRE.
Corrective Action:
DEALERS WILL INSPECT THE FRONT AND REAR BRAKE CALIPERS FOR CORROSION AND REPLACE OR REBUILD THE CALIPERS AS NECESSARY. THE RECALL BEGAN ON AUGUST 18, 2004. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
September 9, 2002
(Campaign #: NR (Not Reported))
MONACO/FLOOR TRUSS NETWORK
ON CERTAIN CLASS A MOTOR HOMES, THE FLOOR TRUSS NETWORK SUPPORT SYSTEM HAS A POTENTIAL TO WEAKEN CAUSING INTERNAL AND EXTERNAL FEATURES TO BECOME MISALIGNED. THE AFFECTED VEHICLES ARE 1999 - 2003 CLASS A MOTOR HOMES MANUFACTURED ON F53 20,500 POUND GROSS VEHICLE WEIGHT RATING (GVWR), FORD CHASSIS, AND 2000-2003 CLASS A MOTOR HOMES MANUFACTURED ON W-22 22,000 POUND GVWR, WORKHORSE CHASSIS.
NHTSA ID: 02V237000
Component:
# of Units Affected: 6,223
Consequence Summary:
CONDITIONS CAN RESULT IN THE BOTTOMING OUT THE SUSPENSION AND AMPLIFICATION OF THE STRESS PLACED ON THE FLOOR TRUSS NETWORK. THE ADDITIONAL STRESS CAN RESULT IN THE FRACTURE OF WELDS SECURING THE FLOOR TRUSS NETWORK SYSTEM TO THE CHASSIS FRAME RAIL AND/OR FRACTURE OF THE FLOOR TRUSS NETWORK SUPPORT SYSTEM. THE POSSIBILITY EXISTS THAT THERE COULD BE DAMAGE TO ELECTRICAL WIRING AND/OR FUEL LINES WHICH COULD POTENTIALLY LEAD TO A FIRE.
Corrective Action:
DEALERS WILL INSPECT THE FLOOR TRUSS NETWORK SUPPORT SYSTEM, REINFORCE THE EXISTING STRUCTURE, AND REPAIR, AS NEEDED, THE FLOOR TRUSS NETWORK SUPPORT. OWNER NOTIFICATION BEGAN NOVEMBER 5, 2002. OWNERS SHOULD CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2002
(Campaign #: R02182)
MONACO/BATTERY CABLE LOCATION
ON CERTAIN CLASS C MOTOR HOMES, THE BATTERY CABLE IS ROUTED IN A LOCATION THAT ALLOWS EXPOSURE TO HIGH EXHAUST MANIFOLD TEMPERATURES, WHICH COULD DAMAGE THE CABLES.
NHTSA ID: 02V151000
Component: ELECTRICAL SYSTEM
# of Units Affected: 157
Consequence Summary:
AN ELECTRICAL SHORT COULD OCCUR, POTENTIALLY RESULTING IN A FIRE.
Corrective Action:
DEALERS WILL INSPECT THE CABLES FOR DAMAGE AND LOCATION WITHIN THE ENGINE COMPARTMENT. SHOULD DAMAGE BE PRESENT, THE CABLES WILL BE REPLACED. OWNER NOTIFICATION BEGAN JULY 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-685-6545.
Park Outside Advisory: No
Do not Drive Advisory: No
April 9, 2002
(Campaign #: R02198)
MONACO/THROTTLE CONTROL/ACCELERATOR PEDAL
ON CERTAIN MOTOR HOMES EQUIPPED WITH ELECTRONIC THROTTLE CONTROL/ACCELERATOR PEDALS SUPPLIED BY WILLIAMS CONTROLS INDUSTRIES, THE WELD ATTACHING THE CLEVIS TO THE PLATE HAS INSUFFICIENT PENETRATION AND COULD ALLOW THE CLEVIS TO SEPARATE FROM THE PLATE.
NHTSA ID: 02V004007
Component: VEHICLE SPEED CONTROL
# of Units Affected: 232
Consequence Summary:
IF THE CLEVIS SEPARATED FROM THE PLATE WHILE THE VEHICLE WAS IN USE, THE VEHICLE WOULD RETURN TO IDLE, INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THESE PEDALS. OWNER NOTIFICATION BEGAN SEPTEMBER 9, 2002. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-800-344-6332 OR WILLIAMS CONTROL AT 1-503-684-8600.
Park Outside Advisory: No
Do not Drive Advisory: No
April 1, 2002
(Campaign #: NR (Not Reported))
MONACO/CERTIFICATION LABEL
ON CERTAIN TRAVEL TRAILERS, A TYPOGRAPHICAL ERROR WAS MADE, INCORRECTLY STATING THE GROSS VEHICLE WEIGHT RATING ON THE FEDERAL CERTIFICATION LABELS AND RVIA WEIGHT LABELS.
NHTSA ID: 02V102000
Component: EQUIPMENT
# of Units Affected: 45
Consequence Summary:
OWNERS COULD OVERLOAD THE AXLES IF FOLLOWING THE RATINGS AS LISTED.
Corrective Action:
OWNERS WILL BE PROVIDED WITH A CORRECTED LABELS AND INSTALLATION INSTRUCTIONS. OWNER NOTIFICATION BEGAN MAY 30, 2002. OWNERS WHO DO NOT RECEIVE THE FREE LABEL AND INSTALLATION INSTRUCTIONS WITHIN A REASONABLE TIME SHOULD CONTACT MONACO AT 1-877-465-6226.
Park Outside Advisory: No
Do not Drive Advisory: No
January 7, 2002
(Campaign #: NR (Not Reported))
MONACO/MERITOR WABCO/HALDEX/BRAKE VALVES
ON CLASS A MOTOR HOMES BUILT WITH A STEERABLE AUXILIARY AXLE AND EQUIPPED WITH CERTAIN MERITOR-WABCO BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES, THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE BRAKE APPLICATION IS RELEASED.
NHTSA ID: 02V013001
Component: SERVICE BRAKES, AIR
# of Units Affected: 5,956
Consequence Summary:
WHEN THE VALVE STICKS OPEN, IT CAN RESULT IN A TOTAL LOSS OF AIR FROM EITHER THE SERVICE OR THE PARK BRAKE SYSTEM. THE DRIVER MAY LOSE BRAKING ABILITY UNDER A SERVICE APPLICATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Action:
DEALERS WILL REPLACE THESE VALVES. MERITOR WABCO IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT MERITOR WABCO AT 800-535-5560 OR MONACO AT 1-877-466-6226.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.