E-One Incorporated: Safety Recalls in 2024

Updated on March 19, 2026.

There were 6 safety recalls made by E-One Incorporated in 2024. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

October 11, 2024

(Campaign #: NR (Not Reported))

Engine Crossmember May Break

E-One Incorporated (E-One) is recalling certain 2020-2024 Cyclone 2, Typhoon N, 2021- 2024 Cyclone N, and 2021 Quest 2 vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.

NHTSA ID: 24V760000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 282

Consequence Summary:

A damaged cooling fan can result in an engine stall while driving and increase the risk of a crash.

Corrective Action:

Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed November 26, 2024. Owners may contact E-One Customer Service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 41.13

View Full Recall Details

August 30, 2024

(Campaign #: NR (Not Reported))

Engine Crossmember May Break

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, 2022-2024 Cyclone N, and Typhoon N vehicles. The engine crossmember may break, allowing the cooling fan to contact the fan shroud and become damaged.

NHTSA ID: 24V646000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 28

Consequence Summary:

A damaged cooling fan can result in an engine stall while driving and increase the risk of a crash.

Corrective Action:

Dealers will inspect and repair the crossmember as necessary, free of charge. Owner notification letters were mailed September 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 100

View Full Recall Details

July 2, 2024

(Campaign #: NR (Not Reported))

Lower Control Arm Retention Fasteners Can Fail

E-One Incorporated (E-One) is recalling certain 2024 Cyclone N and Typhoon N vehicles equipped with an independent front suspension assembly. The lower control arm retention bolts could become brittle and break after being tightened.

NHTSA ID: 24V501000

Component: SUSPENSION

# of Units Affected: 3

Consequence Summary:

A broken bolt head can become a projectile, increasing the risk of an injury.

Corrective Action:

Dealers will replace the bolts, free of charge. Owner notification letters were mailed August 6, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 66.67

View Full Recall Details

March 12, 2024

(Campaign #: NR (Not Reported))

Overloaded Electrical System May Cause Fire

E-One Incorporated (E-One) is recalling certain 2024 Commercial, Cyclone N, Typhoon N, and Typhoon EV vehicles equipped with Hercules HC 1.7 multiplex nodes. In the event of a short circuit or wiring failure, the firmware in the node may fail to shut off the output pin, resulting in overloaded electrical circuits.

NHTSA ID: 24V194000

Component:

# of Units Affected: 22

Consequence Summary:

Overloaded electrical circuits can overheat, increasing the risk of fire.

Corrective Action:

Weldon will update the firmware, free of charge. Owner notification letters were mailed April 5, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 72.73

View Full Recall Details

January 12, 2024

(Campaign #: NR (Not Reported))

Loss of Power Steering Assist

E-One Incorporated (E-One) is recalling certain 2022-2023 Cyclone 2, Cyclone N, Typhoon N, and 2023 Cyclone E vehicles. The steering assist bracket may have been machined incorrectly.

NHTSA ID: 24V016000

Component:

# of Units Affected: 280

Consequence Summary:

The incorrectly machined bracket may cause a reduction in hydraulic force, requiring greater steering effort and increasing the risk of a crash.

Corrective Action:

Dealers will inspect and replace the steering assist bracket, free of charge. Owner notification letters were mailed February 7, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 58.93

View Full Recall Details

January 8, 2024

(Campaign #: NR (Not Reported))

Overloaded Electrical System May Cause Fire

E-One Incorporated (E-One) is recalling certain 2021-2023 ARFF, Cyclone N, 2020-2024 Commercial, 2020, 2022-2023 Cyclone 2, 2023 Cyclone E, 2022 Typhoon, and 2020-2023 Typhoon N vehicles. In the event of a short circuit or wiring failure, the firmware in the vehicle multiplex system may fail to shut off the output pin, resulting in overloaded electrical circuits.

NHTSA ID: 24V006000

Component: ELECTRICAL SYSTEM

# of Units Affected: 408

Consequence Summary:

Overloaded electrical circuits can overheat, increasing the risk of fire.

Corrective Action:

The equipment manufacturer, Weldon, will update the firmware, free of charge. Owner notification letters were mailed January 24, 2024. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details