E-One Incorporated: Safety Recalls in 2022

Updated on March 19, 2026.

There were 5 safety recalls made by E-One Incorporated in 2022. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

November 18, 2022

(Campaign #: NR (Not Reported))

Exhaust Heat May Cause Fire

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2 and 2020-2021 Typhoon N emergency vehicles. Exhaust heat may build up inside the vehicle body in certain situations such as heavy engine use, possibly causing nearby components to overheat.

NHTSA ID: 22V852000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 8

Consequence Summary:

Overheated components can increase the risk of a fire.

Corrective Action:

Dealers will add an opening to the body top and install a protective grate, free of charge. Owner notification letters were mailed December 12, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 25

View Full Recall Details

October 20, 2022

(Campaign #: NR (Not Reported))

Tie Rod Clamp Failure

E-One Incorporated (E-One) is recalling certain 2022 Cyclone 2, Cyclone N, and Typhoon N vehicles. The tie rod clamps may have been improperly heat-treated, causing them to crack and allowing the tie rods to separate.

NHTSA ID: 22V788000

Component: STEERING

# of Units Affected: 23

Consequence Summary:

Tie rod separation can result in a sudden loss of steering, increasing the risk of a crash.

Corrective Action:

Dealers will replace the tie rod clamps, free of charge. Owner notification letters are expected to be mailed November 30, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 21.74

View Full Recall Details

August 1, 2022

(Campaign #: NR (Not Reported))

Steering Gear Assembled Incorrectly

E-One Incorporated (E-One) is recalling certain 2021-2022 Cyclone N and Typhoon N vehicles. The steering gears may have been assembled incorrectly, which can cause the gears to fracture.

NHTSA ID: 22V561000

Component:

# of Units Affected: 7

Consequence Summary:

A fractured steering gear can cause a loss of steering control, increasing the risk of a crash.

Corrective Action:

Dealers will inspect and replace the steering gears, as necessary, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 14.29

View Full Recall Details

July 26, 2022

(Campaign #: NR (Not Reported))

Electrical Load Center May Overheat

E-One Incorporated (E-One) is recalling certain 2019-2021 Cyclone 2, 2020 Commercial, Quest 2, 2020-2021 Typhoon, 2021 Cyclone N, and 2020-2022 Typhoon N fire trucks. The neutral screw connection within the QO Plug-On Neutral Load Center may be loose. If that connection is loose, the affected load center can overheat.

NHTSA ID: 22V538000

Component:

# of Units Affected: 78

Consequence Summary:

An overheated load center can increase the risk of a fire.

Corrective Action:

Dealers will inspect and repair, or replace the load center, free of charge. Owner notification letters were mailed October 24, 2022. Owners may contact E-One's customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 24.36

View Full Recall Details

May 24, 2022

(Campaign #: NR (Not Reported))

Loss of Vehicle Lighting

E-One Incorporated is recalling certain 2022 Commercial, Cyclone 2, Cyclone N, and Typhoon N fire trucks. An additional resistor was incorrectly installed on the printed circuit board, which can disrupt CAN network communication and cause vehicle lighting to fail.

NHTSA ID: 22V372000

Component:

# of Units Affected: 18

Consequence Summary:

Inoperable vehicle lighting can reduce visibility and increase the risk of a crash.

Corrective Action:

E-One Incorporated will replace the modules, free of charge. Owner notification letters were mailed on July 22, 2022. Owners may contact E-One Incorporated's customer service at 1-352-237-1122.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 16.67

View Full Recall Details