COUNTRY COACH INC: Safety Recalls in 2007
Updated on March 19, 2026.
There were 9 safety recalls made by COUNTRY COACH INC in 2007. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
September 25, 2007
(Campaign #: NR (Not Reported))
SR-7 SPRING BRAKE MODULATING VALVE/BENDIX
ON CERTAIN MOTOR HOMES BUILT ON PREVOST CHASSIS AND EQUIPPED WITH BENDIX SR-7 SPRING BRAKE MODULATING VALVES, THE INTERNAL RUBBER CHECK VALVE MAY LEAK CAUSING A DELAY IN THE APPLICATION OF THE SPRING BRAKES TO PARK THE VEHICLE AFTER THE OPERATOR PULLS THE DASH VALVE BUTTON.
NHTSA ID: 07V448000
Component:
# of Units Affected: 15
Consequence Summary:
THIS COULD CAUSE A DELAY OR FAILURE IN APPLYING THE PARKING BRAKES WHICH COULD RESULT IN A VEHICLE ROLL AWAY, INCREASING THE RISK OF A CRASH.
Corrective Action:
COUNTRY COACH IS WORKING WITH PREVOST AND BENDIX TO REPAIR THESE VEHICLES (PLEASE SEE 07E-037). BENDIX WILL INSTALL A CHECK VALVE REPAIR KIT FOR THE AFFECTED SR-7 SPRING BRAKE MODULATING VALVE FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 25, 2007. OWNERS MAY CONTACT BENDIX AT 1-440-329-9000, PREVOST AT 1-418-831-2046, OR COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
September 21, 2007
(Campaign #: NR (Not Reported))
FUEL PUMP FAILURE TURBOCHARGER/CATERPILLAR
ON CERTAIN MOTOR HOMES EQUIPPED WITH CATERPILLAR C9 DIESEL ENGINES, A FUEL PUMP FAILURE WILL DILUTE THE ENGINE OIL WITH FUEL AND MAY CAUSE THE TURBOCHARGER TO FAIL AND CAUSE LOSS OF THROTTLE CONTROL WITH WARNING.
NHTSA ID: 07V446000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 49
Consequence Summary:
THE WARNING MAY BE EXPERIENCED BY ERRATIC PERFORMANCE AND EXCESSIVE SMOKE. BOTH OF THESE CONDITIONS MAY RESULT IN A SITUATION WHERE A VEHICLE CRASH COULD OCCUR.
Corrective Action:
COUNTRY COACH IS WORKING WITH CATERPILLAR TO HAVE THE FUEL PUMP REPLACED FREE OF CHARGE (PLEASE SEE 07E053). OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR COUNTRY COACH AT 541-998-3720.
Park Outside Advisory: No
Do not Drive Advisory: No
September 20, 2007
(Campaign #: NR (Not Reported))
RANGES/CARBON MONOXIDE POISONING/ATWOOD
ON CERTAIN MOTOR HOMES EQUIPPED WITH ATWOOD SEALED BURNER RANGES, THE RANGE AND SLIDE-IN BURNER TUBES LEADING FROM THE GAS MANIFOLD TO THE BURNER HEADS HAD A DEPRESSION OR 'KINK' IN THE EXTERIOR BEND RESTRICTING PROPER AIRFLOW AND GAS MIXTURE.
NHTSA ID: 07V443000
Component: EQUIPMENT
# of Units Affected: 97
Consequence Summary:
THIS CONDITION COULD RESULT IN CARBON MONOXIDE POISONING.
Corrective Action:
COUNTRY COACH IS WORKING WITH ATWOOD TO HAVE THE TUBES REPLACED ON THESE RANGES. THE RECALL BEGAN ON MAY 3, 2007. OWNERS MAY CONTACT ATWOOD AT 1-800-348-7418 OR COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
June 14, 2007
(Campaign #: NR (Not Reported))
HEAD & TAIL LIGHT ASSEMBLIES/FMVSS108
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AND 45 DEGREES AS SPECIFIED IN THE STANDARD.
NHTSA ID: 07V241000
Component:
# of Units Affected: 1,051
Consequence Summary:
THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A MOTOR VEHICLE CRASH.
Corrective Action:
DEALERS WILL REPLACE THE MARKER LIGHTS ON THE SIDE AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
June 13, 2007
(Campaign #: NR (Not Reported))
CONNECTING ROD FAILURE/CUMMINS
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.
NHTSA ID: 07V239000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 86
Consequence Summary:
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, OIL AND DEBRIS ON THE ROADWAY AND VEHICLE CRASH.
Corrective Action:
COUNTRY COACH IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 800-343-7357 OR COUNTRY COACH AT 1-541-998-3720.
Park Outside Advisory: No
Do not Drive Advisory: No
June 7, 2007
(Campaign #: NR (Not Reported))
FMVSS 108/SIDE MARKER LIGHTS
CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUES OF THE STANDARD.
NHTSA ID: 07V260000
Component:
# of Units Affected: 90
Consequence Summary:
THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A MOTOR VEHICLE CRASH.
Corrective Action:
DEALERS WILL PLACE MARKER LIGHTS ON THE SIDE OF EACH MOTOR HOME AS CLOSE AS REASONABLE TO THE FRONT AND REAR CORNERS AND WIRED INTO THE PARK LIGHT SYSTEM. THE RECALL BEGAN ON MARCH 4, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
June 5, 2007
(Campaign #: NR (Not Reported))
IDENTIFICATION LAMPS/FMVSS 108
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS) NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE MOTOR HOMES WERE EQUIPPED WITH MORE THAN THREE AMBER IDENTIFICATION LAMPS LOCATED AT THE TOP AND FRONT OF THE VEHICLE. ALSO, THE SIDE MARKER LIGHTS IN THE COMBINATION HEADLIGHT AND TAIL LIGHT ASSEMBLIES DO NOT MEET THE MINIMUM PHOTOMETRIC VALUE AT 45 DEGREES AS SPECIFIED IN THE STANDARD.
NHTSA ID: 07V225000
Component:
# of Units Affected: 605
Consequence Summary:
THE FIVE IDENTIFICATION LIGHTS COULD POSSIBLY CAUSE CONFUSION TO ON-COMING MOTORISTS WHO ARE USED TO OBSERVING THREE IDENTIFICATION LIGHTS. THE INADEQUACY OF THE FRONT AND REAR SIDE MARKER LIGHTS COULD AFFECT VISIBILITY OF THE MOTOR HOME DURING HOURS OF DARKNESS THAT COULD POTENTIALLY RESULT IN A CRASH.
Corrective Action:
DEALERS WILL REMOVE THE TWO EXTRA IDENTIFICATION LAMPS AND INSTALL FOUR SIDE MARKER LIGHTS, ONE AT EACH CORNER, FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT MARCH 31, 2008. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
February 1, 2007
(Campaign #: NR (Not Reported))
REFRIGERATOR/DOMETIC
CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR, MANUFACTURED BY THE DOMETIC CORPORATION, MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
NHTSA ID: 07V031000
Component: EQUIPMENT
# of Units Affected: 2,406
Consequence Summary:
RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Corrective Action:
COUNTRY COACH WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). A SECONDARY BURNER HOUSING WILL BE INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON MARCH 28, 2007. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR COUNTRY COACH AT 1-800-452-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
February 1, 2007
(Campaign #: NR (Not Reported))
FRONT AIR BRAKE HOSES
CERTAIN MOTOR HOMES EQUIPPED WITH TUTHILL 1660 INDEPENDENT FRONT SUSPENSION HAVE FRONT AIR BRAKE HOSES THAT COULD POTENTIALLY BE CHAFFED AND RUBBED BY THE STEER AXLE TIRES OR CHASSIS COMPONENTS UNDER CERTAIN CONDITIONS.
NHTSA ID: 07V037000
Component:
# of Units Affected: 51
Consequence Summary:
THESE CONDITIONS CAN POTENTIALLY RESULT IN THE LOSS OF BRAKING INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL RE-ROUTE AND SECURE THE BRAKE HOSES FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2007. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.