COUNTRY COACH INC: Safety Recalls in 2005
Updated on March 19, 2026.
There were 7 safety recalls made by COUNTRY COACH INC in 2005. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
September 14, 2005
(Campaign #: NR (Not Reported))
TIRE AND FEDERAL LABEL REPLACEMENT/FMVSS 120
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THESE MOTOR HOMES WERE INADVERTENTLY ASSIGNED INADEQUATE COLD TIRE INFLATION PRESSURES GIVING THE TIRES A LOWER WEIGHT CARRYING CAPACITY THAN THE FRONT AND REAR AXLE WEIGHT RATINGS.
NHTSA ID: 05V398000
Component:
# of Units Affected: 33
Consequence Summary:
THIS COULD LEAD TO PREMATURE TIRE WEAR AND POTENTIALLY A TIRE FAILURE WHICH COULD RESULT IN THE LOSS OF STEERING CONTROL AND RESULT IN A CRASH.
Corrective Action:
DEALERS WILL REPLACE BOTH THE FRONT AND REAR TIRES AND ISSUE A NEW FEDERAL TIRE LABEL REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURES. THE RECALL BEGAN ON NOVEMBER 7, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
August 29, 2005
(Campaign #: NR (Not Reported))
UNEXPECTED SLIDE ROOM EXTENSION WHILE IN-TRANSIT
ON CERTAIN MOTOR HOMES, THE HYDRAULIC SLIDE ROOM HOSES COULD BLISTER AND LEAK DUE TO ENGINE HEAT.
NHTSA ID: 05V373000
Component: EQUIPMENT
# of Units Affected: 88
Consequence Summary:
LOSS OF HYDRAULIC FLUID COULD CAUSE THE SLIDE ROOM TO UNEXPECTEDLY EXTEND WHILE IN -TRANSIT. THIS CAN RESULT IN A VEHICLE CRASH.
Corrective Action:
DEALERS WILL RELOCATE THE HYDRAULIC HOSES OUTSIDE OF THE ENGINE COMPARTMENT AND REPLACE ANY HOSES THAT EXHIBIT SIGNS OF BLISTERING OR LEAKAGE. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
August 29, 2005
(Campaign #: NR (Not Reported))
BUSS BAR TERMINATION SCREWS
ON CERTAIN MOTOR HOMES,THE ALTERNATING CURRENT POWER DISTRIBUTION PANEL BUSS BAR TERMINATION SCREWS MAY NOT HAVE BEEN TORQUED TO 35 INCH POUNDS.
NHTSA ID: 05V369000
Component: ELECTRICAL SYSTEM
# of Units Affected: 12
Consequence Summary:
IF THE SCREWS ARE NOT TORQUED PROPERLY, THE UNIT COULD HAVE AN ERRATIC POWER SUPPLY OR A COMPLETE LOSS OF POWER. UNEXPLAINED POWER DROPS, LOSS OF GROUND TO THE SYSTEM, HOTSPOTS AT POINTS OF CONNECTION AND IN RARE CIRCUMSTANCES EVEN A FIRE COULD OCCUR.
Corrective Action:
DEALERS WILL INSPECT AND RE-TORQUE ALL THE BUSS TERMINATION BARS IN THE VEHICLE. THE RECALL BEGAN ON SEPTEMBER 12, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
August 16, 2005
(Campaign #: NR (Not Reported))
CIRCUIT BREAKER WIRING
ON CERTAIN MOTOR HOMES, THE USE OF A 20 AMP CIRCUIT BREAKER IN THE 120V AC PANEL FOR AUDIO/VIDEO EQUIPMENT DOES NOT PROTECT THE CIRCUIT AGAINST COMPONENT FAILURES. THE CIRCUIT IS ONLY RATED FOR A 15 AMP CIRCUIT BREAKER.
NHTSA ID: 05V360000
Component: ELECTRICAL SYSTEM
# of Units Affected: 6
Consequence Summary:
THE 20 AMP CIRCUIT BREAKER USED ON THE AUDIO/VIDEO CIRCUIT EXCEEDED THE LOAD CAPACITY OF THE WIRE. THIS COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL REMOVE THE 20 AMP CIRCUIT BREAKER, AND INSTALL A 15 AMP CIRCUIT BREAKER. THE RECALL BEGAN ON AUGUST 29, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
June 14, 2005
(Campaign #: NR (Not Reported))
FMVSS 120/TIRE INFLATION PRESSURES
CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE FRONT AND REAR TIRE COLD TIRE INFLATION PRESSURES OF 125 PSI EXCEED THE MANUFACTURER'S RECOMMENDED MAXIMUM COLD INFLATION PRESSURE OF 120 PSI.
NHTSA ID: 05V277000
Component: TIRES
# of Units Affected: 9
Consequence Summary:
THIS COULD POSSIBLY LEAD TO PREMATURE RIM FAILURE. SUCH A RIM FAILURE COULD RESULT IN THE LOSS OF STEERING CONTROL AND COULD RESULT IN A CRASH.
Corrective Action:
COUNTRY COACH WILL ISSUE REPLACEMENT FEDERAL TIRE LABELS REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURE OF 120 PSI FOR BOTH THE FRONT AND REAR TIRES. THIS CHANGE WILL RESULT IN A REDUCTION OF THE COLD INFLATION TIRE PRESSURE OF EACH FRONT AND REAR TIRE BY 5 PSI. THE RECALL BEGAN ON JUNE 23, 2005. OWNERS MAY CONTACT COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
June 2, 2005
(Campaign #: NR (Not Reported))
RADIUS ROD SUPPORT BOLTS/PREVOST
ON CERTAIN MOTOR HOME SHELLS SUPPLIED BY PREVOST CAR, INC., IT WAS DETERMINED THAT A LARGE QUANTITY OF ANTI-SEIZE COMPOUND WAS USED IN THE MOUNTING OF 3 RADIUS ROD SUPPORTS. THE BOLTS SECURING THE RADIUS ROD SUPPORTS CAN LOOSEN AND COULD COMPLETELY DETACH.
NHTSA ID: 05V253000
Component:
# of Units Affected: 17
Consequence Summary:
A LOOSE ATTACHMENT SHOULD BE DETECTED AT REGULAR INSPECTIONS. THIS CONDITION WILL CREATE SOME UNUSUAL NOISE AND THE VEHICLE STABILITY WILL DETERIORATE GRADUALLY. IF A ROD IS DETACHED COMPLETELY, IT WILL CREATE A LARGE AMOUNT OF NOISE AND THE VEHICLE STABILITY WILL BE REDUCED. THIS COULD RESULT IN A CRASH.
Corrective Action:
PREVOST, IN CONJUNCTION WITH COUNTRY COACH, WILL REINSTALL RADIUS ROD SUPPORTS USING LOCTITE PRODUCT ON THE BOLTS. OWNERS MAY CONTACT PREVOST AT 1-418-831-5432 OR COUNTRY COACH AT 1-800-452-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
May 9, 2005
(Campaign #: NR (Not Reported))
BURNER TUBES /VEHICLE SYSTEMS/WEBASTO
ON CERTAIN CLASS A MOTOR HOMES EQUIPPED WITH VEHICLE SYSTEMS' AQUA-HOT AND HYDRO-HOT WATER HEATERS, WHICH USE WEBASTO BURNER TUBES, THE BURNER TUBES DO NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
NHTSA ID: 05V209000
Component:
# of Units Affected: 282
Consequence Summary:
THE SURFACE TEMPERATURE OF THE EXHAUST TUBE EXITING FROM THE HEATER CAN INCREASE AND COULD POTENTIALLY IGNITE COMBUSTIBLE MATERIALS IN OR AROUND THE VEHICLE.
Corrective Action:
VEHICLE SYSTEMS IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. OWNERS MAY CONTACT VEHICLE SYSTEMS AT 1-800-685-4298 OR COUNTRY COACH AT 1-800-547-8015.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.