COUNTRY COACH INC: Safety Recalls in 2004

Updated on March 19, 2026.

There were 7 safety recalls made by COUNTRY COACH INC in 2004. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

September 21, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/LP GAS COOK TOP HOSE

ON CERTAIN MOTOR HOMES, LIQUID PROPANE (LP) GAS COOK TOPS WERE INSTALLED USING A FLEXIBLE RUBBER HOSE THAT COULD BURN OR MELT.

NHTSA ID: 04V463000

Component: EQUIPMENT

# of Units Affected: 349

Consequence Summary:

IF UNDETECTED, THE HOSE COULD BURN THROUGH AND RESULT IN A LP GAS FIRE.

Corrective Action:

DEALERS WILL REPLACE THE COOK TOP RUBBER HOSE WITH COPPER TUBING. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 21, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/CIRCUIT BREAKER

ON CERTAIN MOTOR HOMES, A CIRCUIT BREAKER IN THE CLEARANCE LIGHT CIRCUIT DOES NOT PROTECT THE CIRCUIT FROM A TOO HIGH AMPERAGE DRAW CAUSED BY A TOWED PASSENGER VEHICLE.

NHTSA ID: 04V464000

Component: ELECTRICAL SYSTEM

# of Units Affected: 380

Consequence Summary:

THE CIRCUIT BREAKER CAN OVERHEAT THE WIRE AND INSULATION TO A POINT WHICH COULD CAUSE A FIRE.

Corrective Action:

DEALERS WILL REPLACE THE DEFECTIVE CIRCUIT BREAKERS. THE RECALL BEGAN ON NOVEMBER 8, 2004. CUSTOMERS CAN CONTACT COUNTRY COACH AT 1-541-998-3720.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

August 26, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/FMVSS-120/FEDERAL TIRE LABEL

CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VHEICLES OTHER THAN PASSENGER CARS.' THE LABELS STATE INADEQUATE COLD TIRE INFLATION PRESSURE FOR THE FRONT TIRES ON THEIR FEDERAL TIRE LABELS.

NHTSA ID: 04V418000

Component: EQUIPMENT

# of Units Affected: 40

Consequence Summary:

IN SOME CASES THIS COULD LEAD TO PREMATURE TIRE WEAR AND POTENTIALLY A TIRE FAILURE WHICH COULD RESULT IN THE LOSS OF STEERING CONTROL AND COULD RESULT IN A CRASH.

Corrective Action:

DEALERS WILL REPLACE FEDERAL TIRE LABELS REFLECTING THE CORRECTED COLD TIRE INFLATION PRESSURE FOR THE FRONT TIRES. THE RECALL BEGAN ON SEPTEMBER 10, 2004. OWNERS SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

June 7, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/HOLLAND USA/STEERING GEAR PLATE

ON CERTAIN MOTOR HOMES EQUIPPED WITH AN INDEPENDENT FRONT SUSPENSION (IFS) GEN II BUILT BY HOLLAND USA, THE GEAR PLATE SUPPORT GUSSETS WERE REMOVED. THIS CAN ALLOW THE PLATE TO FLEX DURING A STATIC STEER CONDITION.

NHTSA ID: 04V259000

Component:

# of Units Affected: 527

Consequence Summary:

THE FLEXING MAY RESULT IN STRESS CRACKING WHICH COULD POTENTIALLY CAUSE A LOSS OF VEHICLE STEERING CONTROL WHICH COULD RESULT IN A VEHICLE CRASH.

Corrective Action:

HOLLAND USA IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. A BOLT-ON STRENGTHENING OF THE STEERING GEAR PLATE WITH U-BOLTS CONNECTING THE CROSS MEMBER TO EACH SIDE OF THE GEAR PLATE AT THE REAR PLUS A TUBE SUPPORT IN THE FRONT WITH J-BOLTS TO THE GEAR PLATE WILL BE INSTALLED. OWNERS SHOULD CONTACT HOLLAND USA CUSTOMER SERVICE AT 1-888-396-6501 FOR INFORMATION AND INSTRUCTIONS FOR WHERE CUSTOMERS CAN TAKE THEIR VEHICLES TO HAVE THE REPAIRS DONE FREE OF CHARGE.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

May 11, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/SLIDE CARGO TRAY RELEASE LEVER

ON CERTAIN MOTOR HOMES, THE STRIKER PLATE OF THE STORAGE BAY COMPARTMENT DOOR LATCH IS POSITIONED IN PROXIMITY TO THE RELEASE MECHANISM LOCATED ON THE FACE OF THE SLIDE CARGO TRAY FRAME.

NHTSA ID: 04V237000

Component: LATCHES/LOCKS/LINKAGES

# of Units Affected: 296

Consequence Summary:

CUSTOMERS CAN CATCH A FINGER WHEN OPERATING THE RELEASE OF THE SLIDE CARGO TRAY.

Corrective Action:

DEALERS WILL INSTALL TWO (2) PULL HANDLES, A LATCH EXTENSION, AND A WARNING LABEL ON EACH AFFECTED SLIDE TRAY. THE RECALL BEGAN ON AUGUST 27, 2004. OWNERS SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

April 26, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/FMVSS 120/INCORRECT TIRE PRESSURES

CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS." THE FRONT TIRES COLD INFLATION PRESSURES ARE INCORRECT. THE CORRECT COLD TIRE PRESSURE SHOULD BE 120 PSI THAT WILL SUPPORT 13,220 POUNDS.

NHTSA ID: 04V198000

Component: EQUIPMENT

# of Units Affected: 50

Consequence Summary:

THIS COULD CAUSE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE DURING NORMAL DRIVING. THE PREMATURE TIRE TREAD WEAR OR TIRE FAILURE COULD LEAD TO A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.

Corrective Action:

DEALERS WILL REMOVE AND REPLACE NEW TIRE LABELS. OWNER NOTIFICATION BEGAN APRIL 30, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

February 2, 2004

(Campaign #: NR (Not Reported))

COUNTRY COACH/FMVSS 120/FRONT AXLE WEIGHT RATING

NHTSA ID: 04V043000

Component:

# of Units Affected: 20

Consequence Summary:

Corrective Action:

DEALERS WILL REPLACE BOTH FRONT TIRES AND THE FRONT AXLE WILL BE RE-RATED TO 12,000 LBS. ALL MOTOR HOMES WILL BE ISSUED NEW FEDERAL TIRE LABELS. OWNER NOTIFICATION IS EXPECTED TO BEGIN FEBRUARY 10, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COUNTRY COACH AT 1-800-547-8015.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details