Volvo Bus Corporation: Safety Recalls in 2024

Updated on March 19, 2026.

There were 3 safety recalls made by Volvo Bus Corporation in 2024. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

November 26, 2024

(Campaign #: SR24-86)

Emergency Exit Label May Detach/FMVSS 217

Volvo Bus Corporation (Volvo Bus) is recalling certain 2025 Volvo 9700 buses. The emergency exit labels that provide exit identification and operating instructions may not be secured properly, allowing the labels to detach. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 217, "Bus Emergency Exits and Window Retention and Release."

NHTSA ID: 24V893000

Component: EQUIPMENT

# of Units Affected: 5

Consequence Summary:

Missing emergency exit labels can prevent or delay the use of the emergency exit, increasing the risk of injury.

Corrective Action:

Prevost will replace the emergency exit labels, free of charge. Owner letters were mailed December 19, 2024. Owners may contact Prevost customer service at 1-866-870-2046. Volvo Bus' number for this recall is SR24-86.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 100

View Full Recall Details

July 9, 2024

(Campaign #: SR24-84)

Steering Gear Link Rod Improperly Tightened

Volvo Bus Corporation (Volvo Bus) is recalling certain 2024 Volvo 9700 vehicles. The castellated nuts securing the steering gear link rod to the steering arm and/or the pitman arm may not have been tightened properly, which can allow it to loosen.

NHTSA ID: 24V524000

Component:

# of Units Affected: 10

Consequence Summary:

A loose steering gear link rod can cause a loss of steering control, increasing the risk of a crash.

Corrective Action:

Prevost will tighten the castellated nuts, free of charge. Owner notification letters were mailed July 18, 2024. Owners may contact Volvo Bus customer service at 1-866-870-2046. Volvo Bus' number for this recall is SR24-84.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 90

View Full Recall Details

February 8, 2024

(Campaign #: SR24-82)

Steering Gear Link Rod May Loosen and Detach

Volvo Bus Corporation (Volvo Bus) is recalling certain 2024 Volvo 9700 vehicles. The castellated nut securing the steering gear link rod to the steering arm may be loose and allow the link rod to detach.

NHTSA ID: 24V083000

Component:

# of Units Affected: 8

Consequence Summary:

A detached link rod can cause a loss of steering control and increase the risk of a crash.

Corrective Action:

Owners are advised not to drive their vehicle until the repair has been performed. Prevost will inspect and tighten the castellated nuts and install new cotter pins as necessary, free of charge. Owner notification letters were mailed February 22, 2024. Owners may contact Volvo Bus customer service at 1-866-870-2046. Volvo Bus' number for this recall is SR24-82.

Park Outside Advisory: No

Do not Drive Advisory: Yes

Completion Rate (%): 100

View Full Recall Details