Thor California, Inc.: Safety Recalls in 2006

Updated on March 19, 2026.

There were 3 safety recalls made by Thor California, Inc. in 2006. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

December 4, 2006

(Campaign #: NR (Not Reported))

REAR CARGO AREA

ON CERTAIN CARGO/TRAVEL TRAILERS, OVERLOADING AND INCORRECTLY POSITIONING CARGO IN THE REAR CARGO AREA CAN RESULT IN ALIGHT HITCH WEIGHT AND AFFECT STABILITY.

NHTSA ID: 06V468000

Component:

# of Units Affected: 117

Consequence Summary:

DEPENDING ON THE SPECIFIC TOW VEHICLE AND ITS HITCH EQUIPMENT, A SUFFICIENTLY LIGHT HITCH WEIGHT CAN RESULT IN SWAY AT HIGHWAY SPEEDS. TOO MUCH WEIGHT INCORRECTLY POSITIONED CAN ALSO RESULT IN SEVERE BENDING OF THE A-FRAME ASSEMBLY, FAILURE OF THE COUPLER ASSEMBLY, AND/OR FAILURE OF THE SAFETY CHAINS. THIS CAN CAUSE A CRASH INVOLVING THE TRAILER AND TOW VEHICLE.

Corrective Action:

DEALERS WILL INSPECT THE TRAILER, TOW VEHICLE AND HITCH EQUIPMENT; INSTALL NEW CARGO LOAD LIMIT LABELS AND PLACARDS IN THE CARGO AREA; FURNISH LOADING LIMIT INFORMATION; REPLACE THE COUPLER AND SAFETY CHAINS; AND REINFORCE THE A-FRAME. THE RECALL BEGAN ON NOVEMBER 15, 2006. OWNERS SHOULD CONTACT THOR AT 1-888-697-8467. NOTE: THIS CAMPAIGN SUPERSEDES A PREVIOUS RECALL (PLEASE SEE 04V243).

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

December 4, 2006

(Campaign #: NR (Not Reported))

OVERLOADING IN THE REAR CARGO AREA

ON CERTAIN CARGO/TRAVEL TRAILERS, THERE IS A POSSIBILITY OF OVERLOADING IN THE REAR CARGO AREA. TOO MUCH WEIGHT INCORRECTLY POSITIONED IN THIS AREA CAN RESULT IN A LIGHT HITCH WEIGHT AND AFFECT STABILITY.

NHTSA ID: 06V466000

Component:

# of Units Affected: 17

Consequence Summary:

DEPENDING ON THE SPECIFIC TOW VEHICLE AND ITS HITCH EQUIPMENT, A SUFFICIENTLY LIGHT HITCH WEIGHT CAN RESULT IN SWAY AT HIGHWAY SPEEDS. THIS COULD CAUSE A CRASH INVOLVING THE TRAILER AND TOW VEHICLE.

Corrective Action:

OWNERS WILL BE ASKED TO INSPECT THEIR TRAILER, TOW VEHICLE, AND HITCH EQUIPMENT AND TO FOLLOW PROPER LOADING PROCEDURES AS EXPLAINED IN THE OWNER'S GUIDE SUPPLEMENT WHICH WILL BE PROVIDED WITH THE OWNER LETTER. THE RECALL BEGAN ON NOVEMBER 15, 2006. OWNERS SHOULD CONTACT THOR AT 1-888-697-8467. NOTE: THIS CAMPAIGN SUPERSEDES A PREVIOUS RECALL (PLEASE SEE 04V242).

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

June 13, 2006

(Campaign #: 615001)

FURNACE EXHAUST VENT

ON CERTAIN TRAVEL AND FIFTH WHEEL TRAILERS EQUIPPED WITH SUBURBAN AND ATWOOD FURNACES, THE FURNACE EXHAUST VENT WAS IMPROPERLY INSTALLED. THE FURNACE EXHAUST VENT WILL ALLOW LEAKAGE OF FUMES WHICH CONTAIN COMBUSTION PRODUCTS, INCLUDING A HIGH CONCENTRATION OF POTENTIALLY LETHAL CARBON MONOXIDE GAS.

NHTSA ID: 06V208000

Component: EQUIPMENT

# of Units Affected: 64,000

Consequence Summary:

FUMES COULD ENTER INTO THE TRAILER AND COULD RESULT IN SERIOUS INJURY OR DEATH.

Corrective Action:

OWNERS WILL RECEIVE INSTRUCTIONS ON INSPECTING THE FURNACE VENT. IF AN OWNER BELIEVES THE VENT IS INSTALLED INCORRECTLY, IS NOT SURE HOW TO INSPECT THE FURNACE EXHAUST VENT, OR NEEDS ASSISTANCE IN GETTING THE FURNACE EXHAUST VENT INSTALLATION INSPECTED AND CORRECTED, OWNERS SHOULD CONTACT THOR IMMEDIATELY AT 1-877-870-2638 OR VIA THE INTERNET AT HTTP://WWW.THORCA.COM. THE RECALL BEGAN ON JUNE 15, 2006.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details