Rhodes Trailers: Safety Recalls in 2003

Updated on March 19, 2026.

There were 2 safety recalls made by Rhodes Trailers in 2003. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

November 4, 2003

(Campaign #: NR (Not Reported))

RHODES/AXLE GREASE

CERTAIN TRAILERS WERE EQUIPPED WITH SYNTHETIC AXLE GREASE. WHEEL BEARING FAILURE OCCURS RESULTING IN DAMAGED WHEEL HUBS, AXLE SPINDLES, WHEEL SEALS, ETC.

NHTSA ID: 03V436000

Component: SUSPENSION

# of Units Affected: 32

Consequence Summary:

EXTREME HEAT CAN OCCUR THAT COULD CAUSE THE AXLE SPINDLE TO SEPARATE FROM THE AXLE AND CAUSE THE TIRES AND WHEELS TO COME OFF WHILE IN OPERATION, WHICH COULD RESULT IN A CRASH.

Corrective Action:

DEALERS WILL REMOVE TIRES AND WHEELS, DISASSEMBLE THE AXLE HUB WHEEL BEARINGS, AND INSPECT AND REPLACE, IF NECESSARY. THE SUSPECT GREASE WILL BE REMOVED AND CLEANED THOROUGHLY. OWNER NOTIFICATION BEGAN SEPTEMBER 26, 2003. OWNERS SHOULD CONTACT RHODES AT 1-304-863-8078.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 1, 2003

(Campaign #: NR (Not Reported))

RHODES/SPRING BRAKE CONTROL

ON CERTAIN DUMP TRAILERS EQUIPPED WITH SEALCO SPRING BRAKE CONTROL VALVE ASSEMBLIES INCORPORATED IN ARVINMERITOR AXLES, PART NOS. 110700 AND 110800, THERE IS A RECESSED AREA ON TOP OF THE VALVE IN WHICH A BRASS GUIDE PIN FITS DOWN INSIDE THE BODY OF THE VALVE AND IS HELD IN PLACE BY A STEEL SNAP RING. THE RECESSED AREA ALLOWS ACCUMULATION OF WATER, DIRT, AND/OR CHEMICALS TO BUILD UP BEHIND THE SNAP RING TO THE POINT WHERE IT WILL NO LONGER CONTAIN THE GUIDE PIN RESULTING IN A FAILURE OF THE AIR VALVE.

NHTSA ID: 03V221000

Component: SERVICE BRAKES, AIR

# of Units Affected: 45

Consequence Summary:

FAILURE OF THE VALVE IN AN EMPTY OR LIGHTLY LOADED TRAILER WHILE THE VEHICLE IS IN MOTION COULD RESULT IN A HARD APPLICATION OF THE SPRING BRAKES, POSSIBLY LOCKING UP THE TRAILER WHEELS AND RESULTING IN A VEHICLE CRASH.

Corrective Action:

SEALCO WILL PROVIDE A REPAIR KIT AND INSTALLATION INSTRUCTIONS TO CUSTOMERS FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SEALCO AT 602-253-1007 OR RHODES AT 304-863-8078.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details