Orange EV: Safety Recalls in 2025
Updated on March 19, 2026.
There were 7 safety recalls made by Orange EV in 2025. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
September 12, 2025
(Campaign #: 2025-SRC-07)
Hazard Lights May Shut Off/FMVSS 108
Orange EV (OEV) is recalling certain 2017-2024 T-Series, 2023-2025 e-TRIEVER, and HUSK-e terminal trucks. The hazard warning lights may turn off when the ignition is in the 'Off' position. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."
NHTSA ID: 25V612000
Component: EXTERIOR LIGHTING
# of Units Affected: 1,378
Consequence Summary:
Hazard lights that do not remain on cannot warn other drivers of a disabled vehicle, increasing the risk of a crash.
Corrective Action:
OEV field service will install a new hazard light wire harness and update the software, free of charge. Owner notification letters were mailed by November 24, 2025. Owners may contact OEV customer service at 1-866-688-5223. OEV's number for this recall is 2025-SRC-07.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 3.77
September 3, 2025
(Campaign #: 2025-SRC-06)
Driveshaft May Contact and Damage Brake Chamber
Orange EV (OEV) is recalling certain 2024-2025 HUSK-e Tandem terminal trucks. The driveshaft may contact and damage the passenger side brake chamber or brake chamber bracket.
NHTSA ID: 25V571000
Component: POWER TRAIN
# of Units Affected: 16
Consequence Summary:
Damaged brake components may cause a reduction of brake performance and unexpected activation of the emergency braking system, increasing the risk of a crash.
Corrective Action:
OEV field service will inspect and replace the driveshaft and brake chamber components as necessary, free of charge. Owner notification letters were mailed December 1, 2025. Owners may contact OEV customer service at 1-866-688-5223. OEV's number for this recall is 2025-SRC-06.
Park Outside Advisory: No
Do not Drive Advisory: Yes
Completion Rate (%): 87.5
June 27, 2025
(Campaign #: 2025-SRC-05)
Incorrect Washer Can Cause Fire
Orange EV (OEV) is recalling certain 2023-2025 HUSK-e terminal trucks previously remedied under Recall 25V367 (2025-SRC-04). The wrong size washer was installed in the thermal fuse bolted joint during the previous repair.
NHTSA ID: 25V445000
Component: ELECTRICAL SYSTEM
# of Units Affected: 20
Consequence Summary:
The incorrect washer can cause the bus bar connection to loosen or open, resulting in electrical arcing and increasing the risk of a fire.
Corrective Action:
OEV will install the correctly sized washer, free of charge. Owner notification letters were mailed August 4, 2025. Owners may contact OEV customer service at 1-866-688-5223. OEV's number for this recall is 2025-SRC-05.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 85
June 2, 2025
(Campaign #: 2025-SRC-04)
Inadequate Fuse Protection Can Cause Fire
Orange EV (OEV) is recalling certain 2023-2025 Husk-e terminal trucks. The high voltage short circuit protection system may have an inadequate fuse.
NHTSA ID: 25V367000
Component: ELECTRICAL SYSTEM
# of Units Affected: 47
Consequence Summary:
In the event of a short, the fuse may open too slowly or not at all, increasing the risk of a fire.
Corrective Action:
OEV will replace the fuse, free of charge. Owner notification letters were mailed June 9, 2025. Owners may contact OEV customer service at 1-866-688-5223. OEV's number for this recall is 2025-SRC-04.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 97.87
May 30, 2025
(Campaign #: 2025-SRC-02)
Upper Steering Shaft Clamp Bolts May be Loose
Orange EV is recalling certain 2023-2025 HUSK-e, e-TRIEVER, and 2022-2024 T-Series trucks. The bolts securing the upper steering shaft clamp may have been improperly tightened.
NHTSA ID: 25V360000
Component: STEERING
# of Units Affected: 968
Consequence Summary:
The loose bolts can cause steering system components to separate, resulting in loss of steering control and increasing the risk of a crash.
Corrective Action:
Orange EV service will replace the upper steering shaft clamp bolts, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Orange EV customer service at 1-866-688-5223.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 33.26
May 20, 2025
(Campaign #: 2025-SRC-03)
Pintle Hook Blocks Backup Light/FMVSS 108
Orange EV is recalling certain 2024 HUSK-e, 2023-2025 e-TRIEVER, and 2017-2024 T-Series trucks. The pintle hook partially blocks the center of the backup lights. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices, and Associated Equipment."
NHTSA ID: 25V328000
Component: EXTERIOR LIGHTING
# of Units Affected: 301
Consequence Summary:
Obstructed backup lights can reduce the vehicle's visibility to pedestrians or other drivers, increasing the risk of a crash.
Corrective Action:
Orange EV service will replace the rear passenger taillight, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Orange EV customer service at 1-866-688-5223.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 25.91
February 27, 2025
(Campaign #: 2025-SRC-01)
Incorrect GAWR on Federal Placard/FMVSS 120
Orange EV is recalling certain 2023-2024 HUSK-e XP terminal trucks. The rear Gross Axle Weight Rating (GAWR) on the federal placard is incorrect and the installed tires and rims may be inadequate for the truck's intended use. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 120, "Wheels and Rims - Other Than Passenger Cars."
NHTSA ID: 25V122000
Component: EQUIPMENT
# of Units Affected: 24
Consequence Summary:
An incorrect GAWR and an inadequate tire and rim combination can lead to unintentionally overloading the vehicle, increasing the risk of a crash.
Corrective Action:
The remedy is currently under development. Owner notification letters were mailed August 18, 2025. Owners may contact Orange EV customer service at 1-866-688-5223.
Park Outside Advisory: No
Do not Drive Advisory: No
Completion Rate (%): 0
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.