Honda (American Honda Motor Co.): Safety Recalls in 2012

Honda is recalling certain model year 2003 and 2004 Pilot and Odyssey and 2003 through 2006 Acura MDX passenger vehicles manufactured from November 26, 2001, through August 30, 2006. The interlock lever of the ignition switch may deform, which can allow the interlock function of a vehicle with an automatic transmission to be defeated.

Honda is recalling certain model year 2012 Civic passenger vehicles, manufactured from October 26, 2012, through October 30, 2012. These vehicles were assembled with the incorrect steering column assembly.

Honda is recalling certain model year 2012 CR-V, equipped with the LX trim level and manufactured from August 30, 2012, to August 31, 2012. These vehicles fail to comply with the requirements of 49 CFR Part 567, "Certification." The incorrect values for Gross Vehicle Weight Rating, Gross Axle Weight Rating front and rear, tire size, and rim size were specified on the safety certification label.

Honda is recalling certain model year 2002-2006 CR-V passenger vehicles, manufactured from February 19, 2002, through July 28, 2006. The driver-side power window switch may fail or melt.

Honda is recalling certain model year 2012 NC700XDC and NC700XC motorcycles. Some motorcycles may be equipped with drive chains that contain outer drive plates that were improperly heat-treated, resulting in plate fracture during use.

Honda is recalling certain model year 2007 through 2011 Element passenger vehicles equipped with an accessory trailer hitch wiring harness. The wire that supplies power to the trailer turn signal lights was inadvertently switched with the stop lamp wire. As a result the turn signals only illuminate when the brake lamps are illuminated. This does not comply with the requirements of Federal Motor Vehicle Safety Standard No. 108, "Lamps, Reflective Devices, and Associated Equipment."

Honda is recalling certain model year 2012 Ridgeline vehicles manufactured on April 18, 2012. An incorrect passenger airbag status indicator may have been installed on the vehicles causing them to fail to conform to the requirements of Federal Motor Vehicle Safety Standard No. 208, "Occupant Crash Protection."

Honda is recalling certain model year 2012 Honda CR-V and model year 2013 Acura ILX vehicles. If the manual or power door lock is activated while an interior front door handle is being operated by an occupant, the cable connecting the interior door handle to the door latch mechanism may become loose and move out of position. There is a possibility that the cable can move far enough out of position to prevent the door from properly latching.

HONDA IS RECALLING CERTAIN MODEL YEAR 2012 HONDA CIVIC VEHICLES. DURING ASSEMBLY, THE PROCESS REQUIRED TO SEAT THE DRIVER’S SIDE DRIVESHAFT AND SET THE RETAINING CLIP WAS NOT COMPLETED. AS A RESULT, THE DRIVESHAFT MAY SEPARATE.

Honda is recalling certain model year 2007 and 2008 Acura TL and model year 2003-2007 Accord V6 vehicles. In May 2012, Honda filed a defect report to recall certain model year 2007 and 2008 Acura TL vehicles. In September 2012, Honda informed the agency that it was including an additional 573,147 vehicles including certain model year 2003 through 2007 Accord V6 vehicles. The total number of vehicles being recalled is now 625,762. Prolonged under-hood and power steering fluid temperatures may cause the power steering hose to deteriorate prematurely, resulting in cracks and power steering fluid leakage.

HONDA IS RECALLING CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V; MODEL YEAR 2003 THROUGH 2005 PILOT; AND MODEL YEAR 2002 AND 2003 CIVIC VEHICLES. IN MARCH 2012, HONDA FILED A DEFECT REPORT TO RECALL CERTAIN MODEL YEAR 2002 THROUGH 2004 CR-V AND CERTAIN MODEL YEAR 2003 PILOT VEHICLES. IN AUGUST 2012, HONDA INFORMED THE AGENCY THAT IT WAS INCLUDING AN ADDITIONAL 820,789 VEHICLES INCLUDING CERTAIN MODEL YEAR 2004 AND 2005 PILOTS AND MODEL YEAR 2002 AND 2003 CIVICS. THE TOTAL NUMBER OF VEHICLES BEING RECALLED IS NOW 1,375,217. DUE TO TENSION FROM THE COMBINATION SWITCH WIRING HARNESS, WEAR ON THE SURFACE OF THE ELECTRICAL TERMINAL CAN OCCUR, YIELDING COPPER OXIDE, WHICH INCREASES ELECTRICAL RESISTANCE. INCREASED ELECTRICAL RESISTANCE MAY CAUSE THE TERMINAL ENDS TO MELT WITHIN THE WIRING HARNESS CONNECTOR.

HONDA IS RECALLING CERTAIN MODEL YEAR 2006 CR-V VEHICLES. THE WELD STRENGTH ATTACHING THE SUB-FRAME BUSHING COLLAR TO THE PASSENGER-SIDE FRONT LOWER ARM IS INSUFFICIENT. THE COLLAR CAN SEPARATE FROM THE ARM DUE TO VIBRATION WHILE DRIVING.

HONDA IS RECALLING CERTAIN MODEL YEAR 2012 PILOT AND ACURA MDX VEHICLES. THE VENT SHUT FLOAT (VSF) VALVE CASE IN THE FUEL TANK ASSEMBLY DOES NOT MEET THE DESIGN SPECIFICATIONS.

HONDA IS RECALLING CERTAIN MODEL YEAR 2008-2009 ODYSSEY VEHICLES, THE GAS-FILLED STRUTS THAT HELP TO RAISE AND SUPPORT THE LIFTGATE OF VEHICLES EQUIPPED WITH A POWER LIFTGATE SYSTEM MAY BE PRONE TO EARLY LIFE FAILURES DUE TO A MANUFACTURING FLAW. THE FLAW CAN RESULT IN A LEAK OF THE PRESSURIZED GAS, LEADING TO REDUCED STRUT PERFORMANCE.

HONDA IS RECALLING CERTAIN MODEL YEAR 2012 ACCORD AND CROSSTOUR VEHICLES. THE DRIVER-SIDE OR PASSENGER-SIDE SIDE CURTAIN AIRBAG INFLATOR MAY NOT HAVE BEEN MANUFACTURED ACCORDING TO CORRECT SPECIFICATIONS.

HONDA IS RECALLING CERTAIN MODEL YEAR 2011-2012 RIDGELINE VEHICLES MANUFACTURED FROM AUGUST 25, 2011, THROUGH NOVEMBER 29, 2011. THE SPARE TIRE INSTALLED IN AFFECTED VEHICLES MAY NOT MATCH THE INFORMATION ON THE VEHICLE’S TIRE INFORMATION PLACARD. THEREFORE, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, “TIRE SELECTION AND RIMS FOR MOTOR VEHICLE.”