FLEETWOOD ENTERPRISES, INC.: Safety Recalls in 2008
Updated on March 19, 2026.
There were 15 safety recalls made by FLEETWOOD ENTERPRISES, INC. in 2008. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
November 24, 2008
(Campaign #: 81120)
PROPANE HOSE CONNECTIONS
FLEETWOOD IS RECALLING 106 MY 2009 ICON AND PULSE 24A MOTOR HOMES. THE PROPANE HOSE CONNECTIONS MAY BE INSTALLED IN A POSITION THAT CAUSES THEM TO BECOME PINCHED AGAINST THE PROPANE TANK.
NHTSA ID: 08V620000
Component: EQUIPMENT
# of Units Affected: 106
Consequence Summary:
THIS MAY RESULT IN DAMAGE TO THE PROPANE HOSE OR FITTINGS AND COULD LEAD TO A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.
Corrective Action:
DEALERS WILL INSPECT AND, IF NECESSARY, REPOSITION THE CONNECTIONS FOR THE PROPANE HOSES. PROPANE HOSES WILL BE INSPECTED AND REPLACED IF DAMAGED. THE RECALL BEGAN ON JANUARY 9, 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-322-8216.
Park Outside Advisory: No
Do not Drive Advisory: No
September 26, 2008
(Campaign #: 80917)
HOLDING TANK STRAPS
FLEETWOOD IS RECALLING 919MY 2008-2009 JAMBOREE SPORT AND TIOGA RANGER MOTOR HOMES. THE POTABLE, GRAY AND BLACK HOLDING TANK STRAPS MAY EXPERIENCE A PREMATURE FATIGUE CONDITION WHICH MAY RESULT IN ONE OF THE TANKS SEPARATING FROM THE MOTOR HOME.
NHTSA ID: 08V504000
Component: EQUIPMENT
# of Units Affected: 919
Consequence Summary:
THIS COULD POSSIBLY RESULT IN PERSONAL INJURY AND/OR A VEHICLE CRASH.
Corrective Action:
DEALERS WILL INSPECT AND REPAIR THE STRAPS. THE RECALL BEGAN ON DECEMBER 10, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
September 26, 2008
(Campaign #: 80918)
PLASTIC EVAPORATIVE EMISSION LINE ASSEMBLY
FLEETWOOD IS RECALLING 1,583 MY 2008-2009 JAMBOREE, JAMBOREE SPORT, JAMBOREE GT, AND TIOGA, TIOGA RANGER, AND TIOGA SL CLASS C MOTOR HOMES BUILT ON A FORD E450 CHASSIS. A SECTION OF HARD PLASTIC EVAPORATIVE EMISSION LINE NEAR THE EVAP SYSTEM CANISTER MAY BE KINKED AND COMPLETELY RESTRICTED. THIS MAY AFFECT A PRESSURE INCREASE IN THE EVAP LINES AND FUEL TANK IN HIGH AMBIENT TEMPERATURES, CAUSING A RELEASE OF EXCESS VAPORS WHEN THE GAS CAP IS REMOVED.
NHTSA ID: 08V505000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 1,583
Consequence Summary:
UNDER CERTAIN CONDITIONS, EXCESS VAPORS AND FUEL MAY BE SPRAYED FROM THE FUEL CAP POSSIBLY RESULTING IN PERSONAL INJURY.
Corrective Action:
DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE KINKED EVAPORATIVE LINE. THE RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
September 26, 2008
(Campaign #: 80911)
PART 567/CERTIFICATION/INCORRECT TIRE PSI RATING
FLEETWOOD IS RECALLING 65 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, AND REVOLUTION L.E. MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." THE LABEL WAS PRINTED WITH THE REAR AND INTERMEDIATE TIRE PSI RATING REVERSED.
NHTSA ID: 08V502000
Component: EQUIPMENT
# of Units Affected: 65
Consequence Summary:
A MISPRINTED LABEL COULD LEAD TO IMPROPER VEHICLE LOADING OR TIRE INFLATION WHICH COULD RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Action:
OWNERS WILL BE PROVIDED WITH CORRECTED CERTIFICATION LABELS AND INSTALLATION INSTRUCTIONS. A DEALER CAN INSTALL THIS LABEL FOR THE OWNER AT NO CHARGE. THE RECALL BEGAN ON OCTOBER 9, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
September 26, 2008
(Campaign #: 80912)
FRONT CLEARANCE LIGHTS WIRING ABRASION
FLEETWOOD IS RECALLING 979 MY 2008-2009 ICON, JAMBOREE, JAMBOREE GT, PULSE, TIOGA, AND TIOGA SL CLASS C MOTOR HOMES. THE FRONT CLEARANCE LIGHTS WIRING MAY COME IN CONTACT WITH A PORTION OF THE METAL MOUNTING PLATE AND COULD BECOME ABRADED.
NHTSA ID: 08V503000
Component:
# of Units Affected: 979
Consequence Summary:
THIS COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL INSPECT THE WIRING AND REPAIR, IF NECESSARY. THE RECALL BEGAN ON FEBRUARY 2, 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
August 7, 2008
(Campaign #: 80724)
ROUTING OF BATTERY CONTROL CENTER
FLEETWOOD IS RECALLING 384 MY 2008 TERRA AND FIESTA MOTOR HOMES. THE BATTERY CONTROL CENTER (BCC) MISCELLANEOUS WIRE HARNESS IS ROUTED BETWEEN FRAMING AT THE DRIVER'S WHEEL WELL AND THE FRONT LEVELING JACK.
NHTSA ID: 08V388000
Component: ELECTRICAL SYSTEM
# of Units Affected: 384
Consequence Summary:
THIS ROUTING CAN CAUSE THE WIRES TO BE PINCHED RESULTING IN SHORTED OR OPEN CIRCUITS WHICH COULD LEAD TO BLOWN FUSES, HOUSE COMPONENT NONOPERATION AND MAY RESULT IN A FIRE.
Corrective Action:
DEALERS WILL INSPECT AND, IF NECESSARY, REROUTE THE BCC MISCELLANEOUS WIRE HARNESS FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 27, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
July 15, 2008
(Campaign #: NR (Not Reported))
REFRIGERATOR/DOMETIC
FLEETWOOD IS RECALLING 70,101 MY 2003-2007 SOUTHWIND, PACE ARROW, BOUNDER, FLAIR, STORM, FIESTA, TERRA GAS CLASS A MOTOR HOMES; BOUNDER, DISCOVERY, PROVIDENCE, EXCURSION, EXPEDITION, REVOLUTION, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION DIESEL CLASS A MOTOR HOMES; JAMBOREE TIOGA CLASS C MOTOR HOMES; AND PROWLER, WILDERNESS, TERRY, MALLARD, PIONEER, PRIDE AND TRIUMPH CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATORS MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
NHTSA ID: 08V320000
Component: EQUIPMENT
# of Units Affected: 70,101
Consequence Summary:
IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Corrective Action:
FLEETWOOD IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR FLEETWOOD AT 1-800-322-8216.
Park Outside Advisory: No
Do not Drive Advisory: No
July 1, 2008
(Campaign #: 80624)
PART 567/CERTIFICATION LABEL INCORRECT
FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.
NHTSA ID: 08V292000
Component: EQUIPMENT
# of Units Affected: 226
Consequence Summary:
OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.
Corrective Action:
FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 28, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2008
(Campaign #: NR (Not Reported))
REFRIGERATOR/FIRE/NORCOLD
FLEETWOOD IS RECALLING CERTAIN CLASS A GAS AND DIESEL MOTOR HOMES, CLASS C MOTOR HOMES, CONVENTIONAL AND FIFTH WHEEL TRAVEL TRAILERS EQUIPPED WITH NORCOLD REFRIGERATORS. A LOW CYCLE FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH GENERATES THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK.
NHTSA ID: 08V240000
Component: EQUIPMENT
# of Units Affected: 1,263
Consequence Summary:
EXTENDED OPERATION OF A LEAKING COOLING UNIT COULD LEAD TO A FIRE FROM GAS WHICH MIGHT ESCAPE.
Corrective Action:
FLEETWOOD IS WORKING WITH NORCOLD TO REPAIR THESE REFRIGERATORS. NORCOLD WILL PROVIDE THERMAL SWITCH KITS TO OWNERS ALONG WITH THE NECESSARY FORMS AND INSTRUCTIONS. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2008. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
May 22, 2008
(Campaign #: 80324)
SEAT BELT ASSEMBLY/FMVSS 209
FLEETWOOD IS RECALLING 186 MY 2008 JAMBOREE SPORT AND TIOGA RANGER 25G CLASS C MOTOR HOMES FOR FAILING TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, "SEAT BELT ASSEMBLIES." THE SEAT BELTS AT THE TWO CENTER SEATING POSITIONS LOCATED ON THE WRAP-AROUND BOOTH DINETTE, MAY BE TOO LONG TO ACHIEVE PROPER ADJUSTMENTS.
NHTSA ID: 08V234000
Component:
# of Units Affected: 186
Consequence Summary:
LACK OF ADEQUATE SEAT BELT PROTECTION INCREASES THE RISK OF PERSONAL INJURY IN THE EVENT OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE TWO SEAT BELTS FREE OF CHARGE. THE RECALLBEGAN ON JUNE 9, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
May 22, 2008
(Campaign #: 80519)
PROPANE PIPE RELOCATION
FLEETWOOD IS RECALLING 135 MY 2004-2006 JAMBOREE GT AND TIOGA SL 29S MODEL MOTOR HOMES. THE BLACK IRON PROPANE PLUMBING, LOCATED UNDER THE MOTOR HOME, MAY COME INTO CONTACT WITH CHASSIS COMPONENTS AND, UNDER CERTAIN CONDITIONS, BECOME PINCHED OR CRUSHED.
NHTSA ID: 08V232000
Component: EQUIPMENT
# of Units Affected: 135
Consequence Summary:
THIS COULD LEAD TO A PROPANE GAS LEAK AND THE POTENTIAL FOR AN EXPLOSION AND/OR FIRE.
Corrective Action:
DEALERS WILL INSPECT AND RELOCATE THE BLACK IRON PROPANE PIPE WITH A KIT THAT PROVIDES THE COMPONENTS TO MOVE THE LINE TO THE SIDE OF THE CHASSIS FRAME RAIL. DEALERS WILL PERFORM THIS REMEDY FREE OF CHARGE. THE RECALL BEGAN ON JUNE 20, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
April 10, 2008
(Campaign #: 80311)
ENTRY STEP ATTACHMENT CRADLE/SUPPORT
FLEETWOOD IS RECALLING 80 MY 2008-2009 PULSE AND ICON CLASS C MOTOR HOMES. THE ENTRY STEP ATTACHMENT CRADLE/SUPPORT MAY BEND CAUSING THE STEP TO BECOME UNSAFE.
NHTSA ID: 08V164000
Component:
# of Units Affected: 80
Consequence Summary:
INSUFFICIENT STRUCTURAL MATERIAL STRENGTH COULD INCREASE THE RISK OF PERSONAL INJURIES AND VEHICLE AND/OR OTHER PROPERTY DAMAGE.
Corrective Action:
DEALERS WILL INSPECT AND REINFORCE THE ENTRY STEP ATTACHMENT CRADLE/SUPPORT FREE OF CHARGE. THE RECALL BEGAN ON MAY 28, 2008.
Park Outside Advisory: No
Do not Drive Advisory: No
March 20, 2008
(Campaign #: 80310)
PART 567/CERTIFICATION/GAWR INCORRECT ON LABEL
FLEETWOOD IS RECALLING 166 MY 2008-2009 PULSE AND ICON CLASS C MOTOR HOMES. THE FEDERAL CERTIFICATION TAG AND CARGO CARRYING CAPACITY TAG WERE PRINTED WITH AN INCORRECT FRONT GROSS AXLE WEIGHT RATING (GAWR) VALUE OF 4,080 POUNDS. THE CORRECT FRONT GAWR IS 4,410 POUNDS.
NHTSA ID: 08V130000
Component: EQUIPMENT
# of Units Affected: 166
Consequence Summary:
THE PURPOSE OF THIS PART IS TO SPECIFY THE CONTENT AND LOCATION OF, AND OTHER REQUIREMENTS FOR, THE CERTIFICATION LABEL TO BE AFFIXED TO MOTOR VEHICLES TO ADDRESS CERTIFICATION-RELATED DUTIES AND LIABILITIES, AND TO PROVIDE THE CONSUMER WITH INFORMATION TO ASSIST HIM OR HER IN DETERMINING WHICH OF THE FEDERAL MOTOR VEHICLE SAFETY STANDARDS ARE APPLICABLE TO THE VEHICLE.
Corrective Action:
FLEETWOOD WILL PROVIDE CORRECT FEDERAL CERTIFICATION AND CARGO CARRYING CAPACITY TAGS AS WELL AS INSTALLATION INSTRUCTIONS TO THE MOTOR HOME OWNERS. IF AN OWNER DESIRES, THEY CAN HAVE THEIR DEALER REPLACE THE TAGS FOR THEM. THE RECALL BEGAN ON JUNE 4, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
February 20, 2008
(Campaign #: 80211)
ENTRY STEP ATTACHMENT CRADLE/SUPPORT
FLEETWOOD IS RECALLING 50 MY 2008 FIESTA AND TERRA MODEL MOTOR HOMES. THE ENTRY STEP ATTACHMENT CRADLE/SUPPORT MAY BEND AS A RESULT OF STEP USAGE AND INSUFFICIENT STRUCTURAL MATERIAL STRENGTH, CAUSING THE STEP TO BECOME UNSTABLE.
NHTSA ID: 08V084000
Component: EQUIPMENT
# of Units Affected: 50
Consequence Summary:
IF THE STEP WERE UNSTABLE, THIS COULD POSSIBLY RESULT IN A RISK OF PERSONAL INJURY, VEHICLE AND/OR OTHER PROPERTY DAMAGE.
Corrective Action:
FLEETWOOD WILL INSPECT AND, IF NECESSARY, REINFORCE THE ENTRY STEP ATTACHMENT CRADLE/SUPPORT. THE RECALL BEGAN ON MARCH 26, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
January 10, 2008
(Campaign #: 71221)
INOPERATIVE INVERTER/MAGNUM
ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.
NHTSA ID: 08V013000
Component: ELECTRICAL SYSTEM
# of Units Affected: 376
Consequence Summary:
OVERHEATING OF THE INVERTER MAY RESULT IN A POTENTIAL FIRE.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE INVERTER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 19, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.