Toyota Motor Engineering & Manufacturing: Safety Recalls in 2010
Updated on March 19, 2026.
There were 17 safety recalls made by Toyota Motor Engineering & Manufacturing in 2010. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
December 13, 2010
(Campaign #: AOP)
STOP LAMP SWITCH BRACKET
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2011 SIENNA VEHICLES. THE BRAKE STOP LAMP SWITCH IS MOUNTED ON A SMALL BRACKET WELDED ON THE LEFT SIDE OF THE SERVICE BRAKE PEDAL SUPPORT ASSEMBLY. DUE TO ITS PROXIMITY TO THE PARKING BRAKE PEDAL, IN LIMITED CIRCUMSTANCES THE STOP LAMP SWITCH BRACKET COULD BE DAMAGED BY THE OPERATOR'S FOOT DURING PARKING BRAKE APPLICATION.
NHTSA ID: 10V620000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 94,126
Consequence Summary:
THIS COULD RESULT IN BRAKE DRAG WITH ASSOCIATED BRAKE NOISE, VIBRATION, AND/OR ILLUMINATION OF THE BRAKE WARNING LIGHT. BRAKING EFFECTIVENESS COULD BE REDUCED INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE BRACKET ASSEMBLY FREE OF CHARGE. TOYOTA PLANS TO MAIL AN INTERIM OWNER NOTIFICATION IN THE MIDDLE OF JANUARY 2011, TO ADVISE OWNERS OF THE RECALL. A SECOND LETTER WILL BE MAILED WHEN PARTS ARE AVAILABLE TO COMPLETE REPAIRS. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
October 21, 2010
(Campaign #: NR (Not Reported))
BRAKE MASTER CYLINDER
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.
NHTSA ID: 10V499000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 728,544
Consequence Summary:
A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Park Outside Advisory: No
Do not Drive Advisory: No
August 26, 2010
(Campaign #: NR (Not Reported))
ENGINE STALLING
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2008 COROLLA AND COROLLA MATRIX VEHICLES. THE ENGINE CONTROL MODULE (ECM) FOR THE SUBJECT MODELS EQUIPPED WITH THE 1ZZ-FE ENGINE AND TWO-WHEEL DRIVE MAY HAVE BEEN IMPROPERLY MANUFACTURED. THERE IS A POSSIBILITY THAT A CRACK MAY DEVELOP AT CERTAIN SOLDER POINTS OR ON VARISTORS ON THE CIRCUIT BOARD.
NHTSA ID: 10V384000
Component:
# of Units Affected: 1,128,659
Consequence Summary:
THERE ARE A VARIETY OF WARNINGS AND CONSEQUENCES ASSOCIATED WITH THE DEFECT. THE ENGINE WARNING LAMP COULD BE ILLUMINATED, HARSH SHIFTING COULD RESULT, THE ENGINE MAY NOT START, OR THE ENGINE COULD SHUT OFF WHILE THE VEHICLE IS BEING DRIVEN. AN ENGINE SHUTOFF WHILE THE VEHICLE IS BEING DRIVEN INCREASES THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSPECT THE PRODUCTION NUMBER OF THE ECM AND REPLACE THE ECM IF NECESSARY. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. TOYOTA WILL MAIL AN INTERIM OWNER NOTIFICATION THE MIDDLE OF SEPTEMBER 2010 TO ADVISE OWNERS OF THIS DEFECT AND RECALL. THIS INTERIM NOTIFICATION WILL INFORM OWNERS THAT THEY WILL RECEIVE A FUTURE NOTIFICATION WHEN PARTS BECOME AVAILABLE TO HAVE THE FREE REMEDY PERFORMED ON THEIR VEHICLE. THE SAFETY RECALL BEGAN ON NOVEMBER 29, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
July 29, 2010
(Campaign #: NR (Not Reported))
STEERING SHAFT
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2003-2007 LEXUS LX470 VEHICLES. THE CONSTRUCTION OF THE STEERING SHAFT IS SUCH THAT THE SNAP RING ON THE SHAFT MAY DISENGAGE WHEN THE VEHICLE EXPERIENCES AN UNUSUALLY SEVERE IMPACT TO THE FRONT WHEELS. IF THE SNAP RING BECOMES DISENGAGED AND THE STEERING WHEEL IS THEN REPEATEDLY TURNED TO THE LOCKED POSITION, OVER TIME THE STEERING SHAFT MAY BECOME DISCONNECTED.
NHTSA ID: 10V346000
Component: STEERING
# of Units Affected: 39,159
Consequence Summary:
THIS COULD RESULT IN LOSS OF STEERING CONTROL INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE SNAP RING WITH A NEWLY DESIGNED ONE AND INSTALL AN ADDITIONAL COMPONENT WHICH WILL PREVENT SEPARATION OF THE STEERING SHAFT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 23, 2010. OWNERS MAY CONTACT LEXUS AT 1-800-255-3987.
Park Outside Advisory: No
Do not Drive Advisory: No
July 29, 2010
(Campaign #: AOH)
STEERING INTERLOCK ASSEMBLY
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2000-2004 AVALON VEHICLES. DUE TO IMPROPER CASTING OF THE STEERING LOCK BAR, THERE IS A POSSIBILITY THAT A MINUTE CRACK MAY DEVELOP ON THE SURFACE OF THE LOCK BAR. SUCH A CRACK MAY EXPAND OVER A LONG PERIOD OF REPEATED LOCK AND UNLOCK OPERATIONS, AND EVENTUALLY THE LOCK BAR COULD BREAK.
NHTSA ID: 10V345000
Component:
# of Units Affected: 372,593
Consequence Summary:
SHOULD THE STEERING LOCK BAR BREAK, THE STEERING WHEEL WOULD LOCK AND THE DRIVER WOULD LOSE THE ABILITY TO STEER THE VEHICLE, INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE STEERING INTERLOCK DEVICE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 7, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
July 6, 2010
(Campaign #: ALE)
ENGINE VALVE SPRINGS
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2006 THROUGH 2008 LEXUS PASSENGER CARS MANUFACTURED FROM AUGUST 26, 2005 THROUGH AUGUST 4, 2008. MICRO-FOREIGN OBJECTS IN THE MATERIAL OF THE VALVE SPRING MAY DEGRADE THE STRENGTH OF THE VALVE SPRING, POSSIBLY CAUSING THE SPRING TO BREAK.
NHTSA ID: 10V309000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 138,874
Consequence Summary:
THE ENGINE COULD FAIL AND STOP SUDDENLY WHILE THE VEHICLE IS IN MOTION, INCREASING THE RISK OF A CRASH.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 2, 2010. OWNERS MAY CONTACT LEXUS AT 1-800-255-3987.
Park Outside Advisory: No
Do not Drive Advisory: No
June 25, 2010
(Campaign #: NR (Not Reported))
FUEL SYSTEM INTEGRITY/FMVSS 301
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 HS250h LEXUS VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 301, "FUEL SYSTEM INTEGRITY." WHEN THE VEHICLE WAS ROTATED FOLLOWING A CRASH TEST AS REQUIRED, THE AMOUNT OF FUEL LEAKAGE EXCEEDED THE ALLOWABLE LIMITS.
NHTSA ID: 10V285000
Component: FUEL SYSTEM, GASOLINE
# of Units Affected: 17,801
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE AFFECTED VEHICLES BY INSTALLING A NEWLY DESIGNED PROTECTOR COMPONENT FOR THE FUEL FILLER INLET PIPE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 9, 2010. OWNERS MAY CONTACT LEXUS AT 1-800-255-3987.
Park Outside Advisory: No
Do not Drive Advisory: No
May 21, 2010
(Campaign #: NR (Not Reported))
STEERING WHEEL OFF-CENTER
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 LEXUS LS460 AND LS600 VEHICLES MANUFACTURED FROM AUGUST 20, 2009 THROUGH MAY 13, 2010. A PROGRAMMING CHANGE OF THE STEERING CONTROL ECU FOR THE VARIABLE GEAR RATIO STEERING (VGRS) SYSTEM CAN CAUSE IMPROPER ACTIVATION OF THE STEERING SYSTEM PROTECTION LOGIC DESIGNED TO PROTECT THE SYSTEM WHEN LARGER THAN NORMAL STEERING INPUTS ARE APPLIED AT A FULLY TURNED POSITION.
NHTSA ID: 10V218000
Component: STEERING
# of Units Affected: 3,800
Consequence Summary:
IMPROPER ACTIVATION OF THE STEERING SYSTEM PROTECTION LOGIC CAN CAUSE THE STEERING WHEEL TO BECOME OFF-CENTERED UP TO 90 DEGREES. THIS MAY OCCUR AFTER THE DRIVER HAS FULLY TURNED THE STEERING WHEEL IN ONE DIRECTION THEN QUICKLY ATTEMPTS TO TURN IT BACK TO THE CENTER POSITION. SHOULD THIS OCCUR WHILE DRIVING, THE RISK OF A CRASH IS INCREASED.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND LEXUS DEALERS WILL REPLACE THE STEERING CONTROL ECU FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
April 30, 2010
(Campaign #: AOG)
VEHICLE STABILITY CONTROL SYSTEM
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2003 SEQUOIA PASSENGER VEHICLES MANUFACTURED FROM APRIL 1, 2002 THROUGH APRIL 17, 2003. THE CENTER POSITION OF THE STEERING ANGLE SENSOR (SAS) MAY NOT BE STORED CORRECTLY DUE TO IMPROPER LOGIC OF THE SKID CONTROL ECU PROGRAMMING. THE VEHICLE STABILITY CONTROL (VSC) SYSTEM COULD ACTIVATE AT LOW SPEED FOR A FEW SECONDS DURING ACCELERATION FROM A STOPPED POSITION.
NHTSA ID: 10V176000
Component:
# of Units Affected: 50,000
Consequence Summary:
SHOULD THIS OCCUR, THE VEHICLE MAY NOT ACCELERATE AS QUICKLY AS THE DRIVER EXPECTS, INCREASING THE RISK OF A CRASH.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REFLASH THE ECU. IF THE REFLASH CANNOT BE COMPLETED ON A PARTICULAR VEHICLE, THE ECU WILL BE REPLACED WITH A NEW ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
April 20, 2010
(Campaign #: ALB)
VEHICLE STABILITY CONTROL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 LEXUS GX460 PASSENGER VEHICLES MANUFACTURED FROM NOVEMBER 16, 2009 THROUGH APRIL 8, 2010. IF THE VEHICLE IS DRIVEN THROUGH A SHARP TURN AT HIGH SPEED, THE VEHICLE MAY SKID IN A SIDEWAYS DIRECTION.
NHTSA ID: 10V159000
Component:
# of Units Affected: 9,400
Consequence Summary:
UNDER CERTAIN CONDITIONS THE VEHICLE COULD ROLL OVER AND A CRASH COULD OCCUR.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES BY REPROGRAMMING THE VEHICLE STABILITY CONTROL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 18, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
April 20, 2010
(Campaign #: AOE)
SPARE TIRE CARRIER ASSEMBLY CABLE CORROSION
TOYOTA IS RECALLING CERTAIN MODEL YEAR 1998 THROUGH 2010 SIENNA PASSENGER VEHICLES MANUFACTURED BETWEEN AUGUST 7, 1997 AND JANUARY 4, 2010, CURRENTLY REGISTERED IN OR ORIGINALLY SOLD IN CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WASHINGTON DISTRICT OF COLUMBIA, VIRGINIA, WEST VIRGINIA, AND WISCONSIN. THE SUBJECT VEHICLES ARE EQUIPPED WITH THE SPARE TIRE STOWED UNDER THE VEHICLE. IF THE VEHICLE IS OPERATED IN THE COLD CLIMATE REGIONS OF THE UNITED STATES WHERE ROAD SALT IS FREQUENTLY USED, WATER SPLASHED BACKWARDS WITH HIGH CONCENTRATIONS OF ROAD SALT CAN REACH THE SPARE TIRE CARRIER AND CORRODE THE SPARE TIRE CARRIER ASSEMBLY CABLE.
NHTSA ID: 10V160000
Component:
# of Units Affected: 600,000
Consequence Summary:
THE CABLE MAY BREAK DUE TO EXCESSIVE CORROSION AND THE SPARE TIRE MAY SEPARATE FROM THE VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS WITH AN INTERIM LETTER INITIALLY INSTRUCTING THEM TO BRING THEIR VEHICLE TO AUTHORIZED DEALERS TO INSPECT FOR CORROSION. A SECOND NOTICE WILL BE SENT WHEN THE PERMANENT REMEDY IS AVAILABLE. FOR MORE INFORMATION, PLEASE SEE TOYOTA'S AMENDED RECALL REPORT OF JULY 19, 2010. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OCTOBER 12, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
March 10, 2010
(Campaign #: NR (Not Reported))
FRONT PROPELLER SHAFT
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TUNDRA VEHICLES WITH FOUR WHEEL DRIVE, THERE IS A POSSIBILITY THAT AN IMPROPER WELD EXISTS AT THE UNION OF THE PROPELLER SHAFT AND YOKE. DUE TO THIS IMPROPER WELD, THIS JOINT MAY SEPARATE AND THE SEPARATED SHAFT MAY COME INTO CONTACT WITH THE ROAD SURFACE.
NHTSA ID: 10V091000
Component: POWER TRAIN
# of Units Affected: 2
Consequence Summary:
THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE FRONT PROPELLER SHAFT FREE OR CHARGE. THE SAFETY RECALL BEGAN ON MARCH 19, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
February 18, 2010
(Campaign #: NR (Not Reported))
DRIVESHAFT FAILURE
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA TACOMA PICKUP TRUCKS. THE PROPELLER SHAFT MAY DEVELOP CRACKS DURING THE MANUFACTURING PROCESS. OVER TIME, THE CRACKS MAY EVENTUALLY LEAD TO THE SEPARATION OF THE PROPELLER SHAFT.
NHTSA ID: 10V042000
Component: POWER TRAIN
# of Units Affected: 8,000
Consequence Summary:
THIS MAY RESULT IN A LOSS OF VEHICLE CONTROL INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE FRONT PROPELLER SHAFT ON AFFECTED VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 22, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
February 9, 2010
(Campaign #: AOB/ALA)
ABS ECU PROGRAMMING
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 TOYOTA PRIUS AND LEXUS HS250H PASSENGER VEHICLES. CUSTOMERS HAVE EXPERIENCED INCONSISTENT BRAKE FEEL AFTER ABS ACTUATION DURING SLOW AND STEADY APPLICATION OF THE BRAKES ON ROUGH OR SLICK ROAD SURFACES. STOPPING DISTANCES MAY BE INCREASED COMPARED WITH A CUSTOMER'S EXPECTATION FOR A GIVEN PEDAL FORCE.
NHTSA ID: 10V039000
Component: SERVICE BRAKES, AIR
# of Units Affected: 148,549
Consequence Summary:
VEHICLE STOPPING DISTANCES MAY INCREASE RELATIVE TO A CUSTOMER'S EXPECTATION INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REWRITE THE PROGRAMMING OF THE ABS CONTROL UNIT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 3, 2010, AND IS EXPECTED TO BE COMPLETED IN LATE MARCH 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.
Park Outside Advisory: No
Do not Drive Advisory: No
February 9, 2010
(Campaign #: AOC)
BRAKE TUBE
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2010 CAMRYS. THE LENGTH OF THE POWER STEERING PRESSURE HOSE ON VEHICLES EQUIPPED WITH THE 4-CYLINDER (2AR-FE) ENGINE MAY BE INSUFFICIENT, SUCH THAT THE GAP BETWEEN THE CRIMP ON THE PRESSURE HOSE AND THE BRAKE TUBE FOR THE LEFT REAR BRAKE MAY BE INSUFFICIENT. UNDER THESE CIRCUMSTANCES THE BRAKE TUBE MAY INTERFERE WITH THE CRIMP AND MAY WEAR AND THEN PERFORATE.
NHTSA ID: 10V040000
Component:
# of Units Affected: 7,314
Consequence Summary:
A BRAKE TUBE PERFORATION MAY RESULT IN BRAKE FLUID LEAKAGE. A LEAK IN BRAKE FLUID MAY IMPACT BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Corrective Action:
TOYOTA WILL NOTIFY OWNERS AND, IF NECESSARY, DEALERS WILL REPLACE OR ADJUST THE BRAKE TUBE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 4, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
January 27, 2010
(Campaign #: 90L)
PEDAL ENTRAPMENT
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
NHTSA ID: 10V023000
Component: VEHICLE SPEED CONTROL
# of Units Affected: 1,126,915
Consequence Summary:
A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Corrective Action:
TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
January 21, 2010
(Campaign #: AOA)
STICKING ACCELERATOR PEDAL
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
NHTSA ID: 10V017000
Component: VEHICLE SPEED CONTROL
# of Units Affected: 2,230,661
Consequence Summary:
THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.