Tiffin Motorhomes, Inc.: Safety Recalls in 2011

Updated on March 19, 2026.

There were 6 safety recalls made by Tiffin Motorhomes, Inc. in 2011. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

November 10, 2011

(Campaign #: NR (Not Reported))

V-BAND CLAMP ASSEMBLY/CUMMINS/FREIGHTLINER CHASSIS

TIFFIN MOTORHOMES, INC. (TIFFIN) IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO AND PHAETON RECREATIONAL VEHICLES BUILT ON FREIGHTLINER CHASSIS AND EQUIPPED WITH A CUMMINS ISC, ISX, ISM, OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

NHTSA ID: 11V547000

Component:

# of Units Affected: 279

Consequence Summary:

IF THE INLET OR OUTLET SECTIONS DISCONNECT, HOT EXHAUST GASES CAN VENT PRIOR TO EXITING THE TAILPIPE, CREATING THE RISK OF COMBUSTION AND A FIRE. IF BOTH CLAMPS FAIL, THERE IS A RISK IN SOME APPLICATIONS THAT THE DOC/DPF HOUSING MAY DETACH COMPLETELY, CREATING A ROAD HAZARD.

Corrective Action:

TIFFIN IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN AT 1-256-356-8661.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 23, 2011

(Campaign #: NR (Not Reported))

V-BAND CLAMP ASSEMBLY/CUMMINS/POWERGLIDE CHASSIS

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2011 ALLEGRO BUS AND PHAETON RECREATIONAL VEHICLES BUILT ON THE POWERGLIDE CHASSIS EQUIPPED WITH A CUMMINS ISX OR ISL DIESEL ENGINE. THE V-BAND CLAMP ASSEMBLY, PART NUMBERS Q187684, Q187685, AND Q187686, USED TO CONNECT THE INLET AND OUTLET CONE SECTIONS TO THE DIESEL OXIDATION CATALYST (DOC)/DIESEL PARTICULATE FILTER (DPF) INCLUDE A T-BOLT WHICH CAN FRACTURE AND FAIL WHEN SUBJECTED TO STRESS OR LOAD. A FRACTURE OR FAILURE OF THE T-BOLT MAY CAUSE THE CLAMP TO LOOSEN AND THE INLET OR OUTLET SECTIONS ATTACHED TO THE DOC/DPF HOUSING TO DISCONNECT.

NHTSA ID: 11V485000

Component:

# of Units Affected: 179

Consequence Summary:

Corrective Action:

TIFFIN MOTORHOMES IS WORKING WITH CUMMINS TO IDENTIFY AND NOTIFY OWNERS OF THE RECALL CAMPAIGN. REPAIRS WILL BE PERFORMED BY AUTHORIZED CUMMINS DEALERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 10, 2011. OWNERS MAY CONTACT CUMMINS AT 1-812-377-5000 OR TIFFIN MOTORHOMES AT 1-256-356-8661.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

August 25, 2011

(Campaign #: NR (Not Reported))

ADJUSTABLE BRAKE PEDAL PIN

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2007-2011 PHAETON, MY 2008-2010 BUS, AND MY 2010 ALLEGRO MOTORHOMES EQUIPPED WITH KONGSBERG AUTOMOTIVE ADJUSTABLE BRAKE PEDALS. THE ADJUSTABLE BRAKE PEDAL ARM MAY LOOSEN ALLOWING THE ARM TO ROTATE AROUND ITS SHAFT AND SWING IN FRONT OF THE ACCELERATOR PEDAL, REDUCING BRAKING FUNCTION.

NHTSA ID: 11V452000

Component: SERVICE BRAKES, HYDRAULIC

# of Units Affected: 1,960

Consequence Summary:

A LOOSE BRAKE PEDAL INCREASES THE RISK OF A CRASH.

Corrective Action:

DAMILER TRUCKS (DTNA) IS PERFORMING RECALL REPAIRS AND NOTIFICATION TO OWNERS. THE OWNERS WERE INITIALLY NOTIFIED BY DTNA TRUCKS ON DECEMBER 22, 2009, AND A FOLLOW UP NOTICE WAS MAILED TO OWNERS ON JULY 20, 2011. OWNERS MAY CONTACT DTNA WARRANTY CLAIMS DEPARTMENT AT 1-800-547-0712 OR TIFFIN MOTORHOMES AT 1-256-356-8661 FOR MORE INFORMATION.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

August 8, 2011

(Campaign #: NR (Not Reported))

EXHAUST PIPE/POSSIBLE FIRE

TIFFIN IS RECALLING CERTAIN MODEL YEAR 2010-2012 PHAETON MOTORHOMES WITH FLOOR PLANS QBH, QKH, AND QTH THAT ARE BUILT WITH 2010 EPA-CERTIFIED ENGINES ON POWERGLIDE CHASSIS. THE EXHAUST PIPE IS MOUNTED TOO CLOSE TO THE UNDERSIDE OF THE FLOOR.

NHTSA ID: 11V416000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 149

Consequence Summary:

MELTING OF THE INSULATION CAN OCCUR, POSSIBLY RESULTING IN A FIRE.

Corrective Action:

TIFFIN WILL NOTIFY OWNERS, AND DEALERS WILL ATTACH A HEAT SHIELD TO THE BOTTOM OF THE FLOOR AND AN INSULATING SOCK OR BLANKET WILL BE WRAPPED AROUND THE EXHAUST PIPE. THESE REPAIRS WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2011. OWNERS MAY CONTACT TIFFIN AT 1-256-356-8661.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 89.93

View Full Recall Details

June 15, 2011

(Campaign #: NR (Not Reported))

HYDRAULIC BRAKE SWITCHES/DTNA

TIFFIN MOTORHOMES IS RECALLING CERTAIN MODEL YEAR 2006-2010, ALLEGRO AND ALLEGRO BAY RECREATIONAL VEHICLES, MANUFACTURED FROM JANUARY 2005, THROUGH APRIL 2010, AND BUILT ON A DAIMLER/FREIGHTLINER CHASSIS. THE BRAKE LIGHTS MAY BE INTERMITTENT DURING LIGHT BRAKE APPLICATIONS.

NHTSA ID: 11V327000

Component: EXTERIOR LIGHTING

# of Units Affected: 1,309

Consequence Summary:

THE BRAKE LIGHTS MAY NOT ILLUMINATE CONSISTENTLY UPON BRAKE APPLICATION AND FAIL TO PROPERLY INDICATE TO A FOLLOWING VEHICLE THAT THE MOTORHOME HAS SLOWED OR COME TO A STOP, INCREASING THE RISK OF A CRASH.

Corrective Action:

DAIMLER TRUCKS (DTNA), MANUFACTURER OF THE CHASSIS, WILL NOTIFY OWNERS AND REPAIRS WILL BE PERFORMED BY DTNA DEALERSHIPS, FREE OF CHARGE. (SEE DTNA'S RECALL CAMPAIGN 10V-178.) THE SAFETY RECALL BEGAN ON MAY 27, 2011. OWNERS MAY CONTACT DTNA AT 1-800-547-0712.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

February 8, 2011

(Campaign #: NR (Not Reported))

REFRIGERATORS/POSSIBLE FIRE/NORCOLD

TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.

NHTSA ID: 11V082000

Component: EQUIPMENT

# of Units Affected: 10,683

Consequence Summary:

THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.

Corrective Action:

TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details