Terex South Dakota, Inc.: Safety Recalls in 2009

Updated on March 19, 2026.

There were 3 safety recalls made by Terex South Dakota, Inc. in 2009. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

May 19, 2009

(Campaign #: CB586)

AERIAL UNITS/LIFT CYLINDER FAILURE

TEREX TELELECT, INC. IS RECALLING 192 MY 1999 THROUGH 2001 HR37 AND HR40 UTILITY TRUCKS MANUFACTURED FROM JUNE 21, 1999 THROUGH JANUARY 30, 2001, WHICH UTILIZE HYDRAULIC CYLINDER 437250D TO LIFT THE LOWER BOOM ASSEMBLY. THESE UNITS WERE BUILT WITH ROD EYE MATERIAL THAT WAS NOT TO SPECIFICATION IN THE LIFT CYLINDER.

NHTSA ID: 09V168000

Component:

# of Units Affected: 192

Consequence Summary:

THE ROD EYE MATERIAL MAY FAIL AND ALLOW THE BOOM AND PLATFORM TO FALL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH TO THE OPERATOR OR PERSONS NEAR THE VEHICLE.

Corrective Action:

TEREX WILL NOTIFY OWNERS AND REPLACE THE LOWER BOOM LIFT CYLINDER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 29, 2009. OWNERS MAY CONTACT TEREX UTILITIES WARRANTY DEPARTMENT BY CALLING 1-605-884-3892.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

May 4, 2009

(Campaign #: CB584)

PUMP FLEX PLATES

TEREX TELELECT, INC. IS RECALLING 142 MY 2008 C4000, C5000, C6000, C7000, AND GENERAL DIGGER DERRICK UTILITY TRUCKS MANUFACTURED BETWEEN SEPTEMBER 11 AND DECEMBER 20, 2008, EQUIPPED WITH EATON 25VQ HYDRAULIC PUMPS. POOR ADHESION OF THE BRONZE MATERIAL AND THE STEEL SURFACE OF THE FLEX PLATE USED IN THE 25VQ SECTION MAY LEAD TO DELAMINATION OF THE BRONZE FROM THE PLATE.

NHTSA ID: 09V149000

Component:

# of Units Affected: 142

Consequence Summary:

FAILURE OF THE PUMP WILL MAKE THE UNIT INOPERABLE AND POSSIBLY LEAVE THE OPERATOR OR LOAD SUSPENDED WHICH COULD RESULT IN PERSONAL INJURY OR DEATH.

Corrective Action:

TEREX WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JULY 31, 2009. OWNERS MAY CONTACT TEREX UTILITIES WARRANTY DEPARTMENT AT 1-605-884-3892.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

April 27, 2009

(Campaign #: CB585)

SERVICE AERIAL DEVICES/MOUNTING PLATE CRACKS

TEREX TELELECT, INC. CERTAIN TLM SERIES AERIAL DEVICES WHICH USED MOUNTING PLATE 471499 INSTALLED ON UTILITY TRUCKS FROM DECEMBER 2002 THROUGH NOVEMBER 2007. THE PLATE CAN DEVELOP A CRACK AT THE BASE OF THE PEDESTAL TO THE TRUCK FRAME.

NHTSA ID: 09E019000

Component:

# of Units Affected: 23

Consequence Summary:

IF THE MOUNTING PLATE FAILS, THE BOOM AND PLATFORM MAY FALL, POSSIBLY RESULTING IN SERIOUS INJURY OR DEATH.

Corrective Action:

TEREX WILL NOTIFY OWNERS AND WILL REINFORCE THE MOUNTING PLATES FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT TEREX UTILITIES WARRANTY BY CALLING 1-605-884-3892.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details