Pierce Manufacturing: Safety Recalls in 2021

Updated on March 19, 2026.

There were 3 safety recalls made by Pierce Manufacturing in 2021. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

May 26, 2021

(Campaign #: 74BX317)

High Pressure Fuel Rail Assembly May Leak Fuel

Pierce Manufacturing (Pierce) is recalling certain 2017-2021 Arrow XT, Enforcer, Impel, Quantum, Saber, and Velocity vehicles. The sealing washer may not seat correctly in the pilot bore holes, allowing the high pressure fuel rail assembly to leak.

NHTSA ID: 21V394000

Component: FUEL SYSTEM, DIESEL

# of Units Affected: 2,416

Consequence Summary:

A fuel leak in the presence of an ignition source increases the risk of a fire.

Corrective Action:

Dealers will inspect the rail threads and fuel lines, and replace the rail as necessary, free of charge. Interim notification letters were mailed to owners on June 24, 2021. Owner notification letters were mailed July 30, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

March 30, 2021

(Campaign #: NR (Not Reported))

Rear LED Lights Too Bright/FMVSS 108

Pierce Manufacturing (Pierce) is recalling certain 2016-2018 Enforcer, Freightliner and Saber vehicles equipped with ECCO Holdings Code 3 7x9 Stop-Tail-Turn Reverse All-in-One LED stop, tail, turn, and reverse lights. The rear LED lights may be too bright. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, "Lamps, Reflective Devices, and Associated Equipment."

NHTSA ID: 21V222000

Component: EXTERIOR LIGHTING

# of Units Affected: 4

Consequence Summary:

The excessive brightness may negatively affect the vision of other drivers, increasing the risk of a crash.

Corrective Action:

Pierce will notify owners, and dealers will provide a filter kit to be installed in the rear lights, free of charge. The recall is expected to begin April 26, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 100

View Full Recall Details

January 13, 2021

(Campaign #: NR (Not Reported))

Wireless Controller Sleep Mode Disabled

Pierce Manufacturing (Pierce) is recalling 2020 Arrow XT, Impel, and Enforcer vehicles equipped with battery-powered 3600 wireless remote controller units used to control the movement of electric firefighting monitors in firefighting vehicles. The monitor is used to direct the water stream and adjust the spray pattern. The wireless remote controller's sleep mode is disabled, and results in the batteries discharging faster than normal.

NHTSA ID: 21V006000

Component:

# of Units Affected: 3

Consequence Summary:

Inability to use the wireless remote controller may hinder the firefighting efforts, increasing the risk of injury.

Corrective Action:

Pierce will notify owners, and dealers will return the affected controllers to Akron Brass for a software update, free of charge. The recall began on February 22, 2021. Owners may contact Pierce customer service at 1-888-974-3723.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 100

View Full Recall Details