NABI Bus, LLC: Safety Recalls in 2004

Updated on March 19, 2026.

There were 4 safety recalls made by NABI Bus, LLC in 2004. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

October 6, 2004

(Campaign #: 20044)

NABI/ENGINE TURBOCHARGER

ON CERTAIN TRANSIT BUSES EQUIPPED WITH DETROIT DIESEL SERIES 50 ENGINES, THE TURBOCHARGER CAN FAIL ALLOWING LUBRICATING OIL TO ENTER THE EXHAUST SYSTEM.

NHTSA ID: 04V479000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 210

Consequence Summary:

IN THE EVENT THE TURBOCHARGER FAILS, A FIRE MAY OCCUR IN THE ENGINE COMPARTMENT RESULTING IN PROPERTY DAMAGE OR INJURIES.

Corrective Action:

DETROIT DIESEL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE ENGINE AND INSTALL AN EXHAUST TEMPERATURE SENSOR TO PREVENT THE POSSIBILITY OF AN EXHAUST OR ENGINE COMPARTMENT FIRE. OWNERS SHOULD CONTACT DETROIT DIESEL CORPORATION AT 313-592-5791 OR NABI AT 1-256-831-4296.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

October 1, 2004

(Campaign #: 20043)

NABI/HYDRAULIC SYSTEM

ON CERTAIN 40' AND 60' TRANSIT BUSES, THE HYDRAULIC SYSTEM THAT PROVIDES POWER TO THE RADIATOR COOLING FAN AND POWER STEERING SYSTEM IS SUBJECT TO BECOMING UNSTABLE.

NHTSA ID: 04V474000

Component: STEERING

# of Units Affected: 690

Consequence Summary:

WHEN THIS OCCURS, THE DRIVER WILL BE SUBJECTED TO HARD TURNING OF THE STEERING WHEEL AND LOSS OF POWER ASSIST IN THE STEERING SYSTEM, INCREASING THE RISK OF A CRASH.

Corrective Action:

NABI IS CONDUCTING THE OWNER NOTIFICATION AND EATON CORPORATION WILL PERFORM THE REMEDY FOR THIS CAMPAIGN. EATON WILL INSPECT AND REPAIR THE HYDRAULIC SYSTEM. THE RECALL BEGAN MARCH 20, 2005. OWNERS SHOULD CONTACT EATON AT 952-967-7168 OR NABI AT 1-888-424-5844.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

July 22, 2004

(Campaign #: 20042)

NABI/FMVSS 217/WINDOW EMERGENCY EXIT

CERTAIN TRANSIT BUSES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 217, "BUS EMERGENCY EXITS AND WINDOW RETENTION AND RELEASE." THERE IS INTERFERENCE BETWEEN THE SIDE DESTINATION SIGN AND THE WINDOW FRAME THAT WILL NOT ALLOW THE WINDOW TO OPEN SUFFICIENTLY.

NHTSA ID: 04V366000

Component:

# of Units Affected: 153

Consequence Summary:

DURING AN EMERGENCY SITUATION, THE FIRST EMERGENCY EGRESS WINDOW LOCATED ON THE CURB SIDE OF THE VEHICLE, IMMEDIATELY BEHIND THE ENTRANCE DOOR, WILL NOT OPEN SUFFICIENTLY TO ALLOW A PERSON TO ESCAPE IN THE EVENT OF AN EMERGENCY, WHICH COULD CAUSE PERSONAL INJURY OR DEATH.

Corrective Action:

NABI WILL INSPECT AND RELOCATE THE SIDE DESTINATION SIGN TO ELIMINATE THIS INTERFERENCE. THE RECALL BEGAN AUGUST 27, 2004. OWNERS MAY CONTACT NABI AT 1-888-424-5844, EXT. 7900.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

February 27, 2004

(Campaign #: 20041)

NABI/WHEEL LUG NUTS

ON CERTAIN TRANSIT BUSES, THE THICKNESS OF THE PAINT ON THE CONTACT SURFACE OF THE WHEELS EXCEEDS THE MAXIMUM THICKNESS RECOMMENDED.

NHTSA ID: 04V102000

Component: WHEELS

# of Units Affected: 180

Consequence Summary:

THE LUG NUTS COULD LOOSEN AND CAUSE PREMATURE WHEEL FAILURE, INCREASING THE RISK OF A CRASH OR INJURY.

Corrective Action:

DEALERS WILL REPAIR OR REPLACE THE WHEELS. OWNER NOTIFICATION BEGANMARCH 5, 2004. OWNERS SHOULD CONTACT NABI AT 1-256-831-4296.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details