Mitsubishi Motors North America, Inc.: Safety Recalls in 2009

Updated on March 31, 2026.

There were 4 safety recalls made by Mitsubishi Motors North America, Inc. in 2009. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

November 5, 2009

(Campaign #: NR (Not Reported))

FRONT SENSOR SAFETY

MITSUBISHI IS RECALLING MODEL YEAR 2008-2009 LANCER AND LANCER EVOLUTION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN AND DISTRICT OF COLUMBIA. IN AREAS WHERE HEAVY ROAD SALT IS USED IN THE WINTER, A LONG TERM EXPOSURE TO A MIXTURE OF MELTED SNOW WITH SALT THROWN UP BY THE OTHER VEHICLES ON THE ROAD MAY CAUSE A WATER-SALT MIXTURE TO ADHERE TO THE FRONT IMPACT SENSORS.

NHTSA ID: 09V435000

Component: AIR BAGS

# of Units Affected: 29,353

Consequence Summary:

THIS COATING OVER TIME MAY CAUSE CORROSION OF THE SENSOR. IN THE EVENT OF A VEHICLE CRASH OF THE TYPE THAT WOULD DEPLOY THE AIRBAGS THIS TYPE OF SHORT-CIRCUIT MAY CAUSE A DELAY IN THE DEPLOYMENT OF THE AIRBAGS WHICH COULD RESULT IN DRIVER OR PASSENGER INJURY.

Corrective Action:

DEALERS WILL INSTALL NEW FRONT AIRBAG SENSORS THAT HAVE IMPROVED CORROSION RESISTANCE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 27, 2009. OWNERS MAY CONTACT MITSUBISHI CUSTOMER RELATIONS DEPARTMENT AT 1-888-648-7820.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 16, 2009

(Campaign #: SR-09-003)

SIDE AIRBAG RETAINER BRACKET

MITSUBISHI MOTORS NORTH AMERICA, INC. (MMNA) IS RECALLING CERTAIN MODEL YEAR 2010 ENDEAVOR MODEL VEHICLES MANUFACTURED BETWEEN MAY 26 AND JULY 28, 2009. THE RETAINER BRACKET USED FOR THE SEAT-MOUNTED SIDE AIRBAG FRAMES ON BOTH THE DRIVER AND FRONT PASSENGER SEATS MAY NOT HAVE BEEN PROPERLY WELDED.

NHTSA ID: 09V361000

Component:

# of Units Affected: 531

Consequence Summary:

IF THIS CONDITION EXISTS, THE FRONT SEAT-MOUNTED AIRBAGS MAY NOT DEPLOY CORRECTLY IN A SIDE IMPACT CRASH, POSSIBLY RESULTING IN INJURY TO THE SEAT OCCUPANT.

Corrective Action:

MMNA WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE WELD CONDITION OF THE SIDE AIRBAG RETAINER BRACKET ON THE FRONT PASSENGER SEATS. IF THE WELD IS INSUFFICIENT, THE DEALER WILL REPLACE THE SEATBACK ASSEMBLY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 30, 2009. OWNERS MAY CONTACT MITSUBISHI CUSTOMER RELATIONS DEPARTMENT AT 1-888-648-7820.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 8, 2009

(Campaign #: SR-09-004)

FUEL RETURN PIPE

MITSUBISHI IS RECALLING MODEL YEAR 2008-2009 LANCER EVOLUTION, RALLIART, AND SPORTBACK RALLIART VEHICLES EQUIPPED WITH TURBOCHARGED ENGINES. THE MANNER IN WHICH THE FUEL RETURN PIPE IS ATTACHED TO THE ENGINE, IN COMBINATION WITH FREQUENT VEHICLE OPERATION AT CERTAIN ENGINE REVOLUTIONS, MAY RESULT IN A RESONANCE THAT, IF CONTINUED OVER TIME, MAY CAUSE A STRESS CRACK TO DEVELOP AT THE FIXED PORTION OF THE FUEL PIPE.

NHTSA ID: 09V349000

Component: FUEL SYSTEM, OTHER

# of Units Affected: 6,903

Consequence Summary:

IF THIS STRESS CRACK DEVELOPS, FUEL LEAKAGE MAY OCCUR. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Corrective Action:

THE FUEL RETURN PIPE WILL BE REPLACED WITH A NEW PART AND TWO ADDITIONAL ATTACHMENT BRACKETS WILL BE INSTALLED TO BETTER CONTROL FUEL PIPE VIBRATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 29, 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-888-648-7820.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

March 10, 2009

(Campaign #: SR-09-002)

BRAKE BOOSTER CHECK VALVE

MITSUBISHI IS RECALLING 39,711 MY 2008-2009 OUTLANDER AND LACER VEHICLES. INCORRECT MATERIAL COMPOSITION OF THE BRAKE BOOSTER CHECK VALVE MAY CAUSE THE CHECK VALVE TO STICK CLOSED WHEN THE ENGINE IS SHUT OFF. WHEN THE VEHICLE IS RE-STARTED AND PUT INTO MOTION, UNDER CERTAIN DRIVING CONDITIONS (VERY SLOW VEHICLE MANEUVERS), THERE MAY BE INSUFFICIENT INITIAL BRAKING ASSIST.

NHTSA ID: 09V077000

Component: SERVICE BRAKES, AIR

# of Units Affected: 39,711

Consequence Summary:

THIS MAY TEMPORARILY INCREASE THE STOPPING DISTANCE OF THE VEHICLE AND THEREFORE INCREASE THE RISK OF A CRASH.

Corrective Action:

DEALERS WILL REPLACE THE BRAKE BOOSTER CHECK VALVE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING APRIL 2009. OWNERS MAY CONTACT MITSUBISHI AT 1-800-222-0037.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details