Keystone RV Company: Safety Recalls in 2010
Updated on March 19, 2026.
There were 15 safety recalls made by Keystone RV Company in 2010. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
December 1, 2010
(Campaign #: 10-152)
SIEMENS BREAKER
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 SPRINTER, COUGAR AND FUZION TRAVEL TRAILERS EQUIPPED WITH SIEMENS AND MURRAY ONE INCH PLUG-IN CIRCUIT BREAKERS. THE "SPRING CLIP" PLUG-IN ASSEMBLY MAY BREAK OR FAIL TO PROVIDE SUFFICIENT FORCE TO MAINTAIN A PROPER ELECTRICAL CONNECTION IN THE PANEL BOARD.
NHTSA ID: 10V606000
Component: ELECTRICAL SYSTEM
# of Units Affected: 2,693
Consequence Summary:
THIS COULD LEAD TO EXCESSIVE TEMPERATURE, ARCING OR THERMAL DAMAGE AT THE CONNECTION POINT AND POTENTIAL DAMAGE TO THE PANEL BOARD'S ELECTRICAL INSULATION WHICH COULD LEAD TO FIRE, PROPERTY DAMAGE, OR PERSONAL INJURY.
Corrective Action:
DEALERS WILL INSPECT THE BREAKERS AND REPLACE AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
November 23, 2010
(Campaign #: 10-153)
TRANSFER SWITCH
KEYSTONE IS RECALLING CERTAIN FIFTH WHEEL TRAILERS WITH A GENERATOR READY OPTION. IF THE TRANSFER SWITCH IS NOT INSTALLED TO THE PROPER SPECIFICATIONS, THE ELEVATED ELECTRICAL LOADS ASSOCIATED WITH THE RECREATIONAL VEHICLE USE IN HIGHER AMBIENT TEMPERATURES MAY CAUSE OVERHEATING OF THE LUGS AND DEGRADING OF THE ELECTRICAL CONNECTIONS.
NHTSA ID: 10V594000
Component:
# of Units Affected: 6,297
Consequence Summary:
OVERHEATING OF THE CONNECTIONS COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE TRANSFER SWITCH IF NECESSARY FREE OF CHARGE. THE SAFETY WAS SUPERCEDED BY CAMPAIGN 11V-577. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
November 23, 2010
(Campaign #: 10-157)
STEEL WHEELS/MIS-ALIGNED WELDS/TREDIT TIRE
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 TRAVEL TRAILERS EQUIPPED WITH 15" X 6" WHITE SPOKE OR MODULAR DESIGN STEEL WHEELS WITH A SIX HOLE BOLT PATTERN. SOME OF THE WHEELS MAY HAVE INADEQUATE WELD PENETRATION BETWEEN THE OUTER RING AND THE CENTER PLATE DUE TO IMPROPER PLATE ALIGNMENT.
NHTSA ID: 10V597000
Component:
# of Units Affected: 2,338
Consequence Summary:
THERE COULD BE A POTENTIAL WHEEL FAILURE AND WHEEL LOSS INCREASING THE RISK OF A CRASH, OR PERSONAL INJURY.
Corrective Action:
KEYSTONE WILL REPLACE THE WHEELS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 15, 2010. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
November 17, 2010
(Campaign #: 10-150)
REFRIGERATORS/POSSIBLE FIRE
KEYSTONE IS RECALLING CERTAIN RECREATIONAL VEHICLES AND FIFTH WHEEL TRAILERS EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
NHTSA ID: 10V587000
Component: EQUIPMENT
# of Units Affected: 4,770
Consequence Summary:
THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Corrective Action:
KEYSTONE IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON DECEMBER 10, 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR KEYSTONE AT 866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
November 11, 2010
(Campaign #: 10-154)
CROSS MEMBERS
KEYSTONE IS RECALLING CERTAIN 2010-2011 MONTANA FIFTH WHEEL TRAILERS MANUFACTURED FROM SEPTEMBER 3, 2009, THROUGH SEPTEMBER 28, 2010. UNDER CERTAIN SIDE LOAD STRESS CONDITIONS THE FRAME EXHIBITS EXCESSIVE FLEXING AT THE AREA OF THE CENTER AXLE SPRING HANGERS.
NHTSA ID: 10V570000
Component: STRUCTURE
# of Units Affected: 576
Consequence Summary:
THIS FLEXING IN EXTREME CIRCUMSTANCES CAN RESULT IN EXTENSIVE FRAME DAMAGE, LEADING TO AN INCREASED RISK OF PROPERTY DAMAGE AND/OR VEHICLE CRASH.
Corrective Action:
KEYSTONE WILL INSTALL A CROSS MEMBER BETWEEN THE CENTER SPRING HANGERS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 23, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
October 27, 2010
(Campaign #: 10-151)
PLUG IN REMOTE CONTROL RECEIVER FOR FIREPLACE
KEYSTONE IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH DIMPLEX ELECTRAFLAME, SYMPHONY, OR OPTIFLAME BRANDED ELECTRIC FIREPLACES, STOVES, AND FIREPLACE INSERTS. THE PLUG IN REMOTE CONTROL RECEIVER FOR THE FIREPLACE CAN OVERHEAT.
NHTSA ID: 10V521000
Component:
# of Units Affected: 5,633
Consequence Summary:
AN OVERHEATED RECEIVER COULD CAUSE A FIRE.
Corrective Action:
KEYSTONE IS WORKING WITH DIMPLEX AND DIMPLEX WILL PROVIDE OWNERS A FREE REPLACEMENT PLUG-IN REMOTE CONTROL KIT. THE SAFETY RECALL BEGAN ON JANUARY 28, 2011. OWNERS MAY CONTACT DIMPLEX NORTH AMERICA CUSTOMER SERVICE AT 1-888-346-7539.
Park Outside Advisory: No
Do not Drive Advisory: No
October 5, 2010
(Campaign #: 10-148)
RANGE/OVEN COMBO/GAS SUPPLY LINE/POSSIBLE FIRE
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2011 RECREATIONAL VEHICLES EQUIPPED WITH ATWOOD 35 SERIES RANGE OVENS. A POTENTIAL EXISTS FOR A SMALL FRACTURE WITHIN THE LINE DELIVERING GAS TO THE OVEN CAVITY BURNER. SUCH A FRACTURE MAY CAUSE PROPANE GAS TO LEAK FROM THE LINE.
NHTSA ID: 10V478000
Component:
# of Units Affected: 5,459
Consequence Summary:
A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE AND/OR EXPLOSION CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY.
Corrective Action:
DEALERS WILL ISOLATE AND PERFORM A DROP PRESSURE TEST ON THE OVEN SUPPLY TUBE AND IF THE TUBE LEAKS IT WILL BE REPLACED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2010. OWNER MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
September 16, 2010
(Campaign #: 10-147)
WHEEL SEPARATION
KEYSTONE IS RECALLING CERTAIN 2011 ALPINE, AVALANCHE, FUZION, LAREDO, MONTANA, AND MOUNTAINEER FIFTH WHEEL TRAILERS MANUFACTURED FROM AUGUST 19, 2010 THROUGH SEPTEMBER 1, 2010, EQUIPPED WITH DEXTER AXLES. ON SOME AXLES, CRACKS COULD APPEAR IN THE SPINDLE WELD.
NHTSA ID: 10V413000
Component: POWER TRAIN
# of Units Affected: 322
Consequence Summary:
THESE CRACKS CAN PROPAGATE AND CAUSE THE SPINDLE TO DETACH FROM THE AXLE TUBE, RESULTING IN THE SEPARATION OF THE WHEEL END FROM THE VEHICLE, CREATING A ROAD HAZARD THAT INCREASES THE RISK OF A CRASH TO OTHER VEHICLES, AND COMPROMISES THE DRIVER'S CONTROL OF THE VEHICLE INCREASING THE RISK OF A VEHICLE CRASH.
Corrective Action:
KEYSTONE WILL NOTIFY OWNERS AND DEALERS WILL INSPECT THE AXLE SERIAL NUMBER AND REPLACE IT IF IT FALLS WITHIN THE SERIAL NUMBER RANGE. REPLACEMENT OF THE AXLE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 24, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
September 3, 2010
(Campaign #: 10-145)
PINCHED WIRE/FIRE
KEYSTONE RV IS RECALLING CERTAIN MODEL YEAR 2009 AND 2010 SPRINTER SELECT 25RB TRAVEL TRAILERS MANUFACTURED FROM FEBRUARY 11 THROUGH NOVEMBER 19, 2009. THE WIRE FROM THE BATTERY TO THE POWER DISTRIBUTION CENTER MAY BE PINCHED BETWEEN THE FLOOR AND THE FRAME.
NHTSA ID: 10V403000
Component: ELECTRICAL SYSTEM
# of Units Affected: 96
Consequence Summary:
IF THE PINCHED WIRE SHORTS, AN INCREASED RISK OF A FIRE CAUSING PROPERTY DAMAGE AND/OR PERSONAL INJURY WILL RESULT.
Corrective Action:
KEYSTON RV WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 13, 2010. OWNERRS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
June 25, 2010
(Campaign #: 10-142)
PROPANE LINE
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 RAPTOR FIFTH WHEEL TRAILERS. THE PROPANE HOSE FOR THE SLIDE ROOM MAY CONTACT THE TIRE AND MAY BECOME DAMAGED AS A RESULT.
NHTSA ID: 10V295000
Component: EQUIPMENT
# of Units Affected: 84
Consequence Summary:
A PROPANE LEAK IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE/AND/OR EXPLOSION CAUSING PROPERLY DAMAGE AND/OR PERSONAL INJURY.
Corrective Action:
DEALERS WILL INSTALL A METAL PLATE TO PREVENT THE PROPANE LINE FROM COMING INTO CONTACT WITH THE TIRE. THE SAFETY RECALL BEGAN ON JUNE 30, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
June 7, 2010
(Campaign #: 10-139)
WASHER DRYER BREAKER
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010-2011 RESIDENCE TRAVEL TRAILERS. A 30 AMP BREAKER WAS INSTALLED ON THE WASHER/DRYER CIRCUIT AND IT NEEDS A 20 AMP BREAKER.
NHTSA ID: 10V241000
Component: EQUIPMENT
# of Units Affected: 43
Consequence Summary:
AN IMPROPER PROTECTED ELECTRICAL CIRCUIT WILL INCREASE THE RISK OF PROPERTY DAMAGE AND PERSONAL INJURY.
Corrective Action:
DEALERS WILL REPLACE THE 30 AMP BREAKER WITH A 20 AMP BREAKER FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 6, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2010
(Campaign #: 10-140)
MISSING EGRESS WINDOW
KEYSTONE RV IS RECALLING CERTAIN MODEL YEAR 2010 AND 2011 COUGAR HIGH COUNTRY FIFTH WHEELS MANUFACTURED FROM APRIL 15 THROUGH MAY 3, 2010. THE REAR BEDROOM IS MISSING AN EGRESS WINDOW.
NHTSA ID: 10V239000
Component: EQUIPMENT
# of Units Affected: 20
Consequence Summary:
IN THE EVENT AN EMERGENCY EVACUATION IS NECESSARY, NOT HAVING THE EGRESS WINDOW WILL INCREASE THE RISK OF PERSONAL INJURY.
Corrective Action:
KEYSTONE RV WILL NOTIFY OWNERS AND THE CURRENTLY INSTALLED WINDOW WILL BE REPLACED WITH AN EGRESS WINDOW FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JULY 2010. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2010
(Campaign #: 10-141)
REMOTE RECEIVER/POSSIBLE FIRE
KEYSTONE RV IS RECALLING CERTAIN MODEL YEAR 2010 RAPTOR FIFTH WHEEL MOTORHOMES MANUFACTURED FROM SEPTEMBER 25, 2009 THROUGH MARCH 2, 2010. THE REMOTE RECEIVER IS NOT COMPATIBLE WITH THE HIGH SPEED LANDING GEAR MOTOR. IF THE MOTOR IS OPERATED IN A BINDING SITUATION, THE REMOTE RECEIVER MAY BE DAMAGED AND OVERHEAT DUE TO AN INADEQUATE BREAKER AND FUSE PROTECTION AND THE EXCESSIVE CURRENT DRAW OF THE MOTOR.
NHTSA ID: 10V238000
Component:
# of Units Affected: 389
Consequence Summary:
CONTINUING TO OPERATE THE LANDING GEAR MOTOR IN THIS CONDITION WILL INCREASE THE RISK OF FIRE.
Corrective Action:
KEYSTONE RV WILL NOTIFY OWNERS AND THE VEHICLES WILL BE REPAIRED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2010. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
February 25, 2010
(Campaign #: 10-129)
SPARE TIRE CARRIER
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2008-2010 COUGAR AND LAREDO TRAILERS AND FIFTH WHEEL VEHICLES. THESE VEHICLES HAVE EXPERIENCED A LIMITED NUMBER OF FAILURES WITH ITS SPARE TIRE CARRIERS IN PARTICULAR, THE SPARE TIRE CARRIERS, WHEN COMBINED WITH A 16" SPARE TIRE AND WHEN INSTALLED ON THE BUMPER OF A SLIDE OUT BIKE/STORAGE RACK, MAY BREAK OR CRACK AFTER TIME CAUSING THE SPARE TIRE TO FALL OFF.
NHTSA ID: 10V063000
Component: TIRES
# of Units Affected: 2,893
Consequence Summary:
IF THE TIRE CARRIER FAILS CAUSING THE TIRE TO COME LOOSE, THERE IS AN INCREASED RISK OF PERSONAL INJURY AND PROPERTY DAMAGE.
Corrective Action:
THE REMEDY IS TO REPLACE THE SPARE TIRE CARRIER WITH A NEW SPARE TIRE CARRIER FREE OF CHARGE. THE SAFETY RECALL BEGAN ONMARCH 8, 2010. OWNERS MAY CONTACT KEYSTONE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
February 18, 2010
(Campaign #: 10-128)
RAMP DOOR HARDWARE
KEYSTONE IS RECALLING CERTAIN MODEL YEAR 2010 FUZION TRAVEL TRAILERS AND FIFTH WHEELS WITH THE TOURING EDITION II PACKAGE. THE REAR RAMP DOOR CABLE SUPPORT BRACKET BOLTS MAY FAIL WHEN THE DOOR IS USED IN THE PATIO POSITION.
NHTSA ID: 10V044000
Component: STRUCTURE
# of Units Affected: 242
Consequence Summary:
A FALLING DOOR CAN LEAD TO AN INCREASED RISK OF PERSONAL INJURY IF A PERSON IS ON THE DOOR IN THE PATIO POSITION.
Corrective Action:
DEALERS WILL REPLACE THE RAMP DOOR CABLE HARDWARE WITH THE CORRECT HARDWARE FREE OF CHARGE. THE SAFETY RECALLBEGAN ON FEBRUARY 15, 2010. OWNERS MAY CONTACT KEYSTONE CUSTOMER SERVICE AT 1-866-425-4369.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.