Keystone RV Company: Safety Recalls in 2004

Updated on March 19, 2026.

There were 3 safety recalls made by Keystone RV Company in 2004. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

December 7, 2004

(Campaign #: NR (Not Reported))

KEYSTONE/WIRING ROUTED INCORRECTLY OVER TANK

ON CERTAIN TRAVEL TRAILERS, DURING PRODUCTION, THE WIRING WAS ROUTED OVER THE TOP OF THE GRAY HOLDING TANK ON THE BACKSIDE IN A LOCATION WHERE THE WIRING COULD BECOME PINCHED BY THE HEAT PLENUM FRAMING.

NHTSA ID: 04V577000

Component: ELECTRICAL SYSTEM

# of Units Affected: 28

Consequence Summary:

PINCHED WIRING COULD CAUSE AN ELECTRICAL SHORT. ELECTRIC POWER MAY BECOME IN-OPERABLE IN AFFECTED UNITS DUE TO BREAKERS BEING TRIPPED.

Corrective Action:

DEALERS WILL RE-ROUTE THE WIRING. THE RECALL BEGAN DECEMBER 10, 2004. OWNERS SHOULD CONTACT KEYSTONE AT 574-535-2100.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

May 10, 2004

(Campaign #: NR (Not Reported))

KEYSTONE/DIMMER SWITCH PLATE

ON CERTAIN TRAVEL TRAILERS, THE DIMMER SWITCH FACE PLATE CAN MELT AROUND THE SLIDE CONTROL.

NHTSA ID: 04V223000

Component:

# of Units Affected: 267

Consequence Summary:

THE SWITCH CAN BECOME HOT ENOUGH TO MELT THE FACE PLATE.

Corrective Action:

DEALERS WILL INSPECT AND REPLACE THE FACE PLATE. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT KEYSTONE AT 1-866-273-1454.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

March 31, 2004

(Campaign #: NR (Not Reported))

KEYSTONE/HITCH PIN

ON CERTAIN MODEL RP3612 DS FW FIFTH WHEEL RECREATIONAL VEHICLES, CRACKING IN THE STEEL SURROUNDING THE PINBOX (HITCH) CAN OCCUR. THE CRACKS ARE SPECIFICALLY IN THE ATTACHMENT WELDS BETWEEN THE PINBOX AND THE SURROUNDING FRAME STRUCTURE.

NHTSA ID: 04V157000

Component: TRAILER HITCHES

# of Units Affected: 71

Consequence Summary:

THIS CAN CAUSE PARTIAL OR COMPLETE SEPARATION OF THE PINBOX FROM THE FRAME INCREASING THE RISK OF A CRASH.

Corrective Action:

DEALERS WILL REPLACE THE PINBOX WITH AN AIR-RIDE PINBOX. OWNER NOTIFICATION BEGAN FEBRUARY 23, 2004. OWNERS SHOULD CONTACT KEYSTONE AT 1-866-425-4369.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details