Kalmar Solutions, LLC: Safety Recalls in 2015

Updated on March 19, 2026.

There were 3 safety recalls made by Kalmar Solutions, LLC in 2015. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

June 9, 2015

(Campaign #: NR (Not Reported))

Vent Tube May Detach from Engine Breather

Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2010-2014 Ottawa tractors manufactured December 6, 2010, to July 21, 2014, equipped with certain Cummins Westport ISL G engines. Excessive engine crankcase pressures may cause the 90-degree elbow of the vent tube assembly to detach from the crankcase ventilation breather, possibly allowing engine oil to come into contact with hot surfaces.

NHTSA ID: 15V357000

Component: ENGINE AND ENGINE COOLING

# of Units Affected: 22

Consequence Summary:

If engine oil comes into contact with a hot surface, there is an increased risk of a fire.

Corrective Action:

Cummins will notify owners on behalf of Kalmar, and dealers will secure the ends of the 90-degree elbow. In addition, the electronic control module (ECM) will be reprogrammed with software that can adjust the engine output under misfire conditions to limit crankcase pressures. These repairs will be performed free of charge. The recall began on June 12, 2015. Owners may contact Kalmar customer service at 1-785-229-6327 or Cummins customer service at 1-800-343-7357.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

March 26, 2015

(Campaign #: NR (Not Reported))

Wiring for ABS Components is Crossed

Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2015 Kalmar Ottawa T2 terminal tractors manufactured September 15, 2014, to February 10, 2015. The affected vehicles have the wiring for the rear axle antilock brake system (ABS) components wired incorrectly. Specifically, the left side components are connected to the right side of the ABS control module and vice versa.

NHTSA ID: 15V177000

Component: SERVICE BRAKES, AIR

# of Units Affected: 52

Consequence Summary:

If the communication between the ABS components and the module is reversed, it can cause vehicle instability during braking, increasing the risk of a vehicle crash.

Corrective Action:

Kalmar will notify owners, and dealers will correct the ABS wiring, free of charge. The recall is expected to begin April 27, 2015. Owners may contact Kalmar customer service at 1-785-229-6327.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 59.62

View Full Recall Details

March 11, 2015

(Campaign #: NR (Not Reported))

Battery Ground may Disconnect and Harness may Melt

Kalmar Solutions, LLC (Kalmar) is recalling certain model year 2014-2015 Ottawa terminal tractors manufactured June 20, 2014, to November 14, 2014. Due to improper routing, the battery ground cable may detach from its mounting on the transmission, and as a result, excessive current may travel through the vehicle's engine harness, melting it.

NHTSA ID: 15V140000

Component: ELECTRICAL SYSTEM

# of Units Affected: 311

Consequence Summary:

Melting of the engine harness may cause an electrical short and increase the risk of a fire.

Corrective Action:

Kalmar will notify owners, and dealers will replace the battery cable and correct its routing to eliminate stress on its attachment point, free of charge. The recall began on March 26, 2015. Owners may contact Kalmar customer service at 1-785-229-6327.

Park Outside Advisory: No

Do not Drive Advisory: No

Completion Rate (%): 46.3

View Full Recall Details