Jayco, Inc.: Safety Recalls in 2006
Updated on March 19, 2026.
There were 18 safety recalls made by Jayco, Inc. in 2006. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
August 31, 2006
(Campaign #: NR (Not Reported))
JUMPER WIRE
ON CERTAIN FIFTH WHEEL TRAILERS, A JUMPER WIRE BETWEEN THE TWO NEUTRAL BARS IS NOT OF ADEQUATE GAUGE.
NHTSA ID: 06V331000
Component: ELECTRICAL SYSTEM
# of Units Affected: 260
Consequence Summary:
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN AN ELECTRICAL FIRE.
Corrective Action:
DEALERS WILL REPLACE THE 12/14 GAUGE JUMPER WIRE WITH A 6 GAUGE JUMPER WIRE FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 1, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
August 30, 2006
(Campaign #: NR (Not Reported))
SPEED CONTROL DEACTIVATION SWITCH/FORD
ON CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
NHTSA ID: 06V320000
Component:
# of Units Affected: 6,285
Consequence Summary:
OVERHEATING COULD RESULT IN SMOKE OR BURNING, AND IN AN UNDERHOOD FIRE.
Corrective Action:
FORD IS CONDUCTING THIS RECALL (PLEASE SEE 06V286) AND WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-866-436-7332 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
August 2, 2006
(Campaign #: NR (Not Reported))
OUTLET KITCHEN COUNTER TOP
ON CERTAIN TRAVEL TRAILERS, THE OUTLET MOUNTED A THE END OF THE KITCHEN COUNTER TOP DOES NOT MEET NFPA 70 NATIONAL ELECTRIC CODE ARTICLE 5511V NOMINAL 120 VOLT OR 120/240-VOLT SYSTEMS 551.41 (C) GROUND -FAULT CIRCUIT-INTERRUPTER PROTECTION.
NHTSA ID: 06V287000
Component: EQUIPMENT
# of Units Affected: 162
Consequence Summary:
THIS COULD CAUSE AN ELECTRICAL SHORT, WHICH COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL REWIRE TO A GROUND-FAULT CIRCUIT INTERRUPTER CIRCUIT FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 24, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
June 14, 2006
(Campaign #: NR (Not Reported))
SAFETY BELT BUCKLE/GM/CHEVROLET
ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS, THE SAFETY BELT BUCKLES MAY NOT LATCH OR UNLATCH.
NHTSA ID: 06V210000
Component:
# of Units Affected: 49
Consequence Summary:
IN THE EVENT OF A CRASH, A SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED INCREASING THE RISK OF PERSONAL INJURY OR DEATH.
Corrective Action:
GENERAL MOTORS IS CONDUCTING THIS RECALL (PLEASE SEE 05V558000) AND WILL INSPECT THE BUCKLES AND, IF FOUND TO BE INOPERATIVE, THE ENTIRE BUCKLE ASSEMBLY WOULD BE REPLACED. FOR BUCKLES FOUND TO BE OPERATIVE, DEALERS WILL REPLACE ONLY THE UPPER BUCKLE COVER. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438 OR JAYCO AT 1-574-825-0608.
Park Outside Advisory: No
Do not Drive Advisory: No
April 19, 2006
(Campaign #: NR (Not Reported))
FMVSS 110/INCORRECT TIRE LABEL PLACARD INFORMATION
CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, 'TIRE SELECTION AND RIMS.' THE FEDERAL IDENTIFICATION LABEL AND THE TIRE LOADING INFORMATION PLACARD HAS THE INCORRECT TIRE INFLATION LISTED.
NHTSA ID: 06V123000
Component: EQUIPMENT
# of Units Affected: 85
Consequence Summary:
MISPRINTED LABELS COULD LEAD TO FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION RECOMMENDATION WHICH COULD RESULT IN TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Action:
OWNERS WILL BE PROVIDED WITH NEW TIRE INFORMATION PLACARDS AND INSTALLATION INSTRUCTIONS. AT THE CUSTOMER'S OPTION, A DEALER CAN PERFORM THE INSTALLATION FOR THEM. THE RECALL BEGAN ON APRIL 28, 2006. OWNERS MAY CONTACT JAYCO AT 574-825-0608.
Park Outside Advisory: No
Do not Drive Advisory: No
April 10, 2006
(Campaign #: NR (Not Reported))
INCORRECT CERTIFICATION LABEL/FMVSS 120/FORD
CERTAIN MOTOR HOMES BUILT ON FORD E-450 CHASSIS, AND EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.
NHTSA ID: 06V109000
Component: EQUIPMENT
# of Units Affected: 135
Consequence Summary:
AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.
Corrective Action:
OWNERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267 .
Park Outside Advisory: No
Do not Drive Advisory: No
March 31, 2006
(Campaign #: NR (Not Reported))
ENGINE STALLING/FORD
CERTAIN MOTOR HOMES BUILT ON FORD CHASSIS MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
NHTSA ID: 06V095000
Component: ELECTRICAL SYSTEM
# of Units Affected: 1,107
Consequence Summary:
SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Corrective Action:
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 30, 2006
(Campaign #: NR (Not Reported))
WIPER MOTOR GREASE/FORD
ON CERTAIN MOTOR HOMES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
NHTSA ID: 06V091000
Component: VISIBILITY
# of Units Affected: 112
Consequence Summary:
AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Corrective Action:
FORD IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. ALL VEHICLES HAVE BEEN REMEDIED.
Park Outside Advisory: No
Do not Drive Advisory: No
March 30, 2006
(Campaign #: NR (Not Reported))
WEAK WELDS CONVERTER MUFFLERS
ON CERTAIN MOTOR HOMES EQUIPPED WITH CATERPILLAR DIESEL ENGINES, THE STRAPS THAT SUPPORT THE CONVERTER MUFFLERS TO THE CHASSIS, THESE WELDS ARE CAUSING THE STRAPS TO FAIL.
NHTSA ID: 06V089000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 3
Consequence Summary:
WHEN THE STRAPS FAIL, THE MUFFLER CAN DROP TO THE GROUND.
Corrective Action:
CATERPILLAR IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. CATERPILLAR WILL HAVE THE CONVERTER MUFFLER STRAPS REPLACED FREE OF CHARGE. OWNERS MAY CONTACT CATERPILLAR AT 309-675-6496 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 30, 2006
(Campaign #: NR (Not Reported))
BOSCH/HYDRO-BOOST/HYDRAULIC BRAKE
ON CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS AND EQUIPPED WITH BOSCH HYDRO-BOOST BRAKE ASSEMBLIES, THE HYDRAULIC BRAKE BOOSTER PRESSURE ACCUMULATOR MAY CRACK AND SEPARATE FROM THE HYDRO-BOOST ASSEMBLY DURING NORMAL OPERATING CONDITIONS.
NHTSA ID: 06V088000
Component:
# of Units Affected: 199
Consequence Summary:
IF A SEPARATION OCCURRED AND THE HOOD OF THE VEHICLE WERE OPEN, FRAGMENTS FROM THE ACCUMULATOR COULD CAUSE INJURY TO PEOPLE IN THE IMMEDIATE AREA. THE PRESENCE OF THIS CRACK OR FRACTURED SURFACE COULD ALLOW THE HYDRAULIC FLUID TO LEAK FROM THE ACCUMULATOR CIRCUIT OF THE BOOSTER ASSEMBLY. THE LOSS OF FLUID WOULD CAUSE INCREASED STEERING AND BRAKING EFFORT AND A CRASH MAY OCCUR WITHOUT PRIOR WARNING.
Corrective Action:
CHEVROLET IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. CHEVROLET WILL TEST THE HYDRO-BOOST ASSEMBLY FOR FUNCTIONAL OPERATION OF THE TWO-FUNCTION VALVE. IF THE HYDRO-BOOST ASSEMBLY FAILS THE TEST, DEALERS ARE TO REPLACE THE ASSEMBLY. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 30, 2006
(Campaign #: NR (Not Reported))
BODY WIRING HARNESS/GM
CERTAIN MOTOR HOMES BUILT ON CHEVROLET CHASSIS WERE PRODUCED WITH A BODY WIRING HARNESS WITH NO PROTECTIVE CONDUIT IN THE AREA UNDER THE DRIVER'S FEET TO REDUCE THE POTENTIAL FOR HARNESS WEAR. THE BODY WIRING HARNESS INCLUDES SDM WIRING THAT COULD BE DAMAGED FROM CHAFING AND WEAR BY THE VEHICLE OPERATORS.
NHTSA ID: 06V084000
Component: ELECTRICAL SYSTEM
# of Units Affected: 183
Consequence Summary:
THIS COULD RESULT IN INADVERTENT AIR BAG DEPLOYMENT. A PERSON MAY RECEIVE MINOR INJURIES, SUCH AS ABRASIONS, FROM CONTACT WITH THE BAG.
Corrective Action:
GENERAL MOTORS/CHEVROLET DIVISION IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. CHEVROLET WILL INSPECT THE WIRING HARNESS FOR POTENTIAL DAMAGE, REPAIR OR REPLACE THE HARNESS IF REQUIRED, AND ADD CONDUIT TO ALL HARNESSES. OWNERS SHOULD CONTACT CHEVROLET AT 1-800-630-2438 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 29, 2006
(Campaign #: NR (Not Reported))
PRESSURE GAUGE FALSE READING/SPARTAN/AMETEK
ON CERTAIN MOTOR HOMES EQUIPPED WITH NGI AIR PRESSURE GAUGES LOCATED ON THE DASH PANEL, THE GAUGE IS GIVING A FALSE READING.
NHTSA ID: 06V083000
Component: SERVICE BRAKES, AIR
# of Units Affected: 21
Consequence Summary:
THIS MAY CAUSE THE PARK BRAKE TO ENGAGE WITHOUT WARNING, THUS THROWING THE PASSENGER FORWARD, INCREASING THE RISK OF INJURY TO OCCUPANTS.
Corrective Action:
SPARTAN IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSTALL A HARNESS JUMPER CABLE TO EACH AIR SENDER. OWNERS MAY CONTACT SPARTAN AT 1-517-543-6400 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 28, 2006
(Campaign #: NR (Not Reported))
AIR FILTER ELEMENT MATERIAL
ON CERTAIN MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION, COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
NHTSA ID: 06V082000
Component:
# of Units Affected: 1,107
Consequence Summary:
THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Corrective Action:
FORD MOTOR COMPANY IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
March 21, 2006
(Campaign #: NR (Not Reported))
INSTRUMENT CLUSTER/FMVSS 101/105/WORKHORSE
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH ACTIA CORPORATE INSTRUMENT CLUSTERS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD (FMVSS)NOS. 101 "CONTROLS AND DISPLAYS" AND NO. 105 "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE INCORRECT SOFTWARE PROGRAMMED INTO THE INSTRUMENT PANEL CLUSTER SUCH THAT CERTAIN DRIVER WARNINGS REQUIRED BY FMVSS 101 AND 105 ARE NOT DISPLAYED. AS A RESULT OF THIS INCORRECT SOFTWARE, THE INSTRUMENT PANEL CLUSTER MAY FAIL TO ILLUMINATE WARNING LAMPS INDICATING BRAKE SYSTEM FAILURE CODES.
NHTSA ID: 06V079000
Component:
# of Units Affected: 44
Consequence Summary:
DRIVERS WOULD NOT BE WARNED OF BRAKE SYSTEM FAILURES.
Corrective Action:
JAYCO IS WORKING WITH WORKHORSE TO NOTIFY OWNERS AND HAVE THE REPAIR PERFORMED ON THEIR VEHICLES. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-246-7731 OR JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
February 14, 2006
(Campaign #: NR (Not Reported))
FUEL PUMP LEAKAGE
ON CERTAIN FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH THE OPTIONAL FUEL STATION, THE FUEL PUMP CAN LEAK.
NHTSA ID: 06V049000
Component: FUEL SYSTEM, GASOLINE
# of Units Affected: 278
Consequence Summary:
FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL REPLACE THESE PUMPS. THE RECALL BEGAN ON MARCH 14, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
January 27, 2006
(Campaign #: NR (Not Reported))
HYDRAULIC BRAKE LINE P-CLAMP
ON CERTAIN CAMPING TRAILERS, THE HYDRAULIC BRAKE LINE P-CLAMP WAS INCORRECTLY INSTALLED. THIS MAY CAUSE THE METAL BRAKE LINE ELBOW BETWEEN THE BRAKE HOSE AND THE BACKING PLATE TO BREAK WHILE TRAVELING DOWN THE ROAD LEADING TO THE LOSS OF BRAKING CAPABILITIES.
NHTSA ID: 06V022000
Component:
# of Units Affected: 254
Consequence Summary:
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.
Corrective Action:
DEALERS WILL REMOVE THE BRAKE HOSE P-CLAMP AND REPLACE THE METAL BRAKE LINE ELBOWS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 14, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
January 23, 2006
(Campaign #: NR (Not Reported))
WIRING HARNESS/EXHAUST TAIL PIPE
ON CERTAIN MOTOR HOMES, THE WIRE HARNESS MAY HAVE BEEN ROUTED TOO CLOSE TO THE EXHAUST TAIL PIPE WHICH MAY RESULT IN THE CABLE MELTING AND CREATING AN ELECTRICAL SHORT.
NHTSA ID: 06V016000
Component: ELECTRICAL SYSTEM
# of Units Affected: 47
Consequence Summary:
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A FIRE, ACCIDENT, INJURY OR DEATH.
Corrective Action:
DEALERS WILL INSPECT, REROUTE AND REPLACE THE WIRE HARNESS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 7, 2006. OWNERS MAY CONTACT JAYCO AT 1-800-283-8267.
Park Outside Advisory: No
Do not Drive Advisory: No
January 13, 2006
(Campaign #: NR (Not Reported))
U-JOINT/DRIVE SHAFT
CERTAIN MOTOR HOMES MAY HAVE U-JOINT RETAINING CLIPS MISSING OR NOT INSTALLED PROPERLY. IF THE RETAINING CLIPS ARE NOT INSTALLED PROPERLY, THE U-JOINT MAY BECOME DISLODGED FROM THE YOKE AND THE DRIVE SHAFT WILL BECOME DISCONNECTED FROM THE DRIVE TRAIN.
NHTSA ID: 06V009000
Component: POWER TRAIN
# of Units Affected: 62
Consequence Summary:
THIS CONDITION, IF NOT ADDRESSED, COULD RESULT IN A CRASH, INJURY OR DEATH.
Corrective Action:
DEALERS HAVE COMPLETED THE REPAIRS TO 100 PERCENT OF THE UNITS AT THE FACTORY AND AT DEALERSHIPS. NO FURTHER ACTION IS NECESSARY ON THIS RECALL.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.