International Motors, LLC: Safety Recalls in 2008

NAVISTAR IS RECALLING 977 MY 2009 INTERNATIONAL 3200, 4100, 4300, 4400 TRUCKS AND IC BUS HC COMMERCIAL BUSES. THE FRONT AXLE BEARINGS IN SOME CASES WERE NOT SUFFICIENTLY LUBRICATED DURING ASSEMBLY WHICH MAY RESULT IN BEARING SEIZING OR POSSIBLE WHEEL SEPARATION.

NAVISTAR IS RECALLING 14,048 MY 2008-2010 LONESTAR AND PROSTAR TRUCKS. THE SERVICE BRAKE AIR LINE THAT RUNS FROM THE TRACTOR PROTECTION VALVE TO THE FAST BRAKE MODULE MAY SEPARATE FROM THE FAST BRAKE MODULE RESULTING IN LOSS OF TRAILER SERVICE BRAKES.

NAVISTAR IS RECALLING 1,607 MY 2007 THROUGH 2009 IC BESB, CESB, FESB, AND RESB SCHOOL BUSES MANUFACTURED FROM JANUARY 4, 2006 THROUGH NOVEMBER 15, 2007, EQUIPPED WITH RICON S OR K SERIES WHEELCHAIR LIFTS. THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT WHICH FAILS TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES."

NAVISTAR IS RECALLING 1,889 IC SCHOOL BUSES MANUFACTURED FROM MAY 4, 2005 THROUGH NOVEMBER 15, 2007, EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.

NAVISTAR IS RECALLING 24,975 MY 2003 THROUGH 2008 IC BE, CE, HC, AND RE SCHOOL AND COMMERCIAL BUSES AND 2002 THROUGH 2008 INTERNATIONAL 3200 AND 3300 MODEL BUSES MANUFACTURED BETWEEN SEPTEMBER 21, 2001 THROUGH DECEMBER 14, 2007, EQUIPPED WITH INTERNATIONAL VT365 ENGINES. THESE VEHICLES MAY EXHIBIT ENGINE HARD START, NO START, OR STALL CONDITIONS DUE TO POSSIBLY DAMAGED TERMINALS IN THE FUSE HOLDER CONNECTOR OF THE INJECTOR DRIVE MODULE (IDM) CLEAN BATTERY POWER CIRCUITS. THE TERMINALS MAY HAVE BEEN DAMAGED DURING ELECTRICAL CONTINUITY TESTING IN THE MANUFACTURING PROCESS.

NAVISTAR IS RECALLING 1,765 MY 1998 THROUGH 2003 RE SCHOOL AND COMMERCIAL BUSES MANUFACTURED BETWEEN JANUARY 5, 1998 AND JULY 23, 2002, EQUIPPED WITH INTERNATIONAL T444E ENGINES. THE HOSE ASSEMBLIES THAT SUPPLY HIGH PRESSURE OIL TO THE ENGINE'S CYLINDER HEADS MAY DETERIORATE AND ALLOW OIL TO LEAK OR MIST IN THE ENGINE COMPARTMENT.

NAVISTAR IS RECALLING 51,588 HEAVY TRUCKS, COMMERCIAL BUSES AND SCHOOL BUSES MANUFACTURED BETWEEN NOVEMBER 21, 2000 AND MAY 21, 2008, EQUIPPED WITH ONE OR MORE REMOTE POWER MODULES. THE POTTING MATERIAL THAT ENCAPSULATES THE CIRCUIT BOARD OF THE VEHICLE'S REMOTE POWER MODULE MAY NOT SUFFICIENTLY SEAL THE CIRCUIT BOARD FROM WATER AND CONTAMINATION INTRUSION. IF THE ENCAPSULATION IS COMPROMISED, WATER AND CONTAMINANTS MAY CAUSE AN INTERNAL ELECTRICAL SHORT, POSSIBLY RESULTING IN A FIRE.

INTERNATIONAL IS RECALLING MY 2007 CE SCHOOL BUSES MANUFACTURED BETWEEN FEBRUARY 8 AND JUNE 27, 2006, EQUIPPED WITH MAXON WHEELCHAIR LIFTS. THE WHEELCHAIR OUTER RETENTION DEVICE LOCATED AT THE END OF THE WHEELCHAIR PLATFORM FAILS TO CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES."

INTERNATIONAL IS RECALLING 330 MY 2008-2009 4000 SERIES TRUCKS AND 3000 RE, FBC, AND SFC BUSES. A MANUFACTURING DEFECT IN THE SUBASSEMBLY OF THE FRONT AXLE WHEEL HUBS RESULTED IN THE BEARINGS BEING INADEQUATELY LUBRICATED. THIS CONDITION COULD CAUSE THE FRONT AXLE BEARINGS TO OVERHEAT WHICH CAN RESULT IN BEARING SPALLING, SEIZING, OR RELATED DAMAGE.

INTERNATIONAL IS RECALLING MY 2008-2009 4000, 5000, 7000, 8000, 9000 AND PROSTAR TRACTOR/TRUCKS EQUIPPED WITH BENDIX MV-3 DASH CONTROL VALVES. THE MOLDED VALVE BODY HAS AN INCORRECT CORE PIN IN THE INJECTION MOLD CAUSING THE VALVE BODY TO BE OVERSIZED IN THE DOUBLE CHECK VALVE AREA. THIS CONDITION CAN ALLOW THE RUBBER DOUBLE CHECK VALVE TO BECOME LODGED IN THE BODY OPENING UNDER CERTAIN CIRCUMSTANCES.

INTERNATIONAL IS RECALLING 34,993 MY 2006-2008 SCHOOL AND TRANSIT BUSES AND HEAVY DUTY TRUCKS/TRACTORS MANUFACTURED BETWEEN JUNE 1, 2006 AND JUNE 28, 2007, EQUIPPED WITH INTERNATIONAL DT466 OR DT570 ENGINES. THE BASE PLATE OF THE ENGINE OIL COOLER MAY CRACK ALLOWING PRESSURIZED OIL TO LEAK INTO THE ENGINE COMPARTMENT.

ON CERTAIN TRUCKS, THE RETENTION SYSTEM OF THE PIN THAT ATTACHES THE HOOD TRAVEL LIMITING SHOCK TO THE MOUNTING BRACKET ON TOP OF THE RADIATOR MAY BECOME DISABLED DUE TO INTERFERENCE BETWEEN IT AND THE GRAB HANDLE POCKET OF THE HOOD. THIS COULD ALLOW THE PIN TO WORK OUT OF THE CONNECTION RESULTING IN THE HOOD SEPARATING FROM THE SHOCK.

INTERNATIONAL IS RECALLING 1,027 MY 2006-2007 BE, CE, FE, AND RE SCHOOL AND COMMERCIAL BUSES MANUFACTURED FROM JULY 11, 2005 THROUGH JULY 31, 2006, AND EQUIPPED WITH BRAUN PLATFORM LIFTS FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." A PASSENGER CAN APPROACH THE EXPOSED LIFT DOORWAY WITHOUT THE AUDIBLE ALARM ALERTING THEM OF THEIR PROXIMITY TO THE THRESHOLD.