FEDERAL-MOGUL CORPORATION: Safety Recalls in 2006

Updated on March 19, 2026.

There were 3 safety recalls made by FEDERAL-MOGUL CORPORATION in 2006. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

June 6, 2006

(Campaign #: NR (Not Reported))

AFTERMARKET HUB ASSEMBLIES

CERTAIN FEDERAL-MOGUL NATIONAL AND CARQUEST AFTERMARKET HUB ASSEMBLIES, P/N 515058, SOLD FOR USE ON 2001-2006 GENERAL MOTORS 1500 AND 2500 4WD TRUCKS. ON THE SUBJECT HUB ASSEMBLIES, THE ABS SENSOR CORD DEPARTS FROM THE HUB ASSEMBLY AT A 90 DEGREE ANGLE. AS A RESULT, THERE IS A FIT ISSUE WITH THE BRAKE ROTOR DUST SHIELD INTERFERING WITH THE ABS SENSOR CORD. IF THE HUB ASSEMBLY IS INSTALLED DESPITE THIS INTERFERENCE, THE GAP BETWEEN THE ABS SENSOR AND THE TONE WHEEL MAY BE ALTERED. THIS MAY WEAKEN THE OUTPUT OF THE ABS SENSOR. DIMINISHED OUTPUT COULD RESULT IN AN UNWANTED ABS ACTIVATION AT LOW SPEEDS AND STOPPING DISTANCE COULD BE AFFECTED.

NHTSA ID: 06E050000

Component:

# of Units Affected: 6,800

Consequence Summary:

IF STOPPING DISTANCE IS LIMITED, A VEHICLE CRASH COULD OCCUR.

Corrective Action:

FEDERAL-MOGUL WILL NOTIFY ITS OWNERS AND WILL EITHER CREDIT THE CUSTOMERS ACCOUNT OR REPLACE THE UNIT. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2006. OWNERS CAN CONTACT FEDERAL-MOGUL CUSTOMER SERVICE AT 1-800-563-8507 EXT 3530.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

January 23, 2006

(Campaign #: NR (Not Reported))

AFTERMARKET ELECTRIC FUEL PUMPS/FUEL LEAK

CERTAIN FEDERAL-MOGUL ELECTRIC FUEL PUMPS SOLD UNDER THE BRAND NAMES OF NAPA AND CARTER, P/NOS. P75040M AND P75043M. THESE PUMPS WERE DISTRIBUTED BETWEEN OCTOBER 31, 2005, AND JANUARY 11, 2006, AND SOLD AS REPLACEMENT EQUIPMENT FOR 1997-2001 JEEP CHEROKEE AND GRAND CHEROKEE VEHICLES. THE AFFECTED PUMPS CONTAIN A DEFECTIVE WIRING HARNESS GROMMET THAT COULD DEGRADE OVER TIME AND ALLOW FUEL TO LEAK.

NHTSA ID: 06E006000

Component: FUEL SYSTEM, OTHER

# of Units Affected: 1,116

Consequence Summary:

IN THE PRESENCE OF AN IGNITION SOURCE, A VEHICLE FIRE COULD OCCUR OR AN EXPLOSION.

Corrective Action:

FEDERAL-MOGUL WILL REPLACE THE ELECTRIC FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 1, 2006. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

January 3, 2006

(Campaign #: NR (Not Reported))

AFTERMARKET FUEL PUMP/LEAKS

CERTAIN FEDERAL-MOGUL MECHANICAL FUEL PUMPS, P/N M847, SOLD UNDER THE BRAND NAMES OF NAPA AND CARTER FOR USE AS REPLACEMENT EQUIPMENT ON VARIOUS PASSENGER VEHICLES. THE FUEL PUMPS WERE SHIPPED BETWEEN MAY 1 AND DECEMBER 20, 2005. THESE FUEL PUMPS CONTAIN A DEFECTIVE VALVE HOUSING THAT COULD ALLOW FUEL TO LEAK.

NHTSA ID: 06E001000

Component: FUEL SYSTEM, GASOLINE

# of Units Affected: 775

Consequence Summary:

FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.

Corrective Action:

FEDERAL-MOGUL WILL NOTIFY CUSTOMERS AND REPLACE THE FUEL PUMPS FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 13, 2006.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details