Cummins, Inc.: Safety Recalls in 2005

Updated on March 19, 2026.

There were 2 safety recalls made by Cummins, Inc. in 2005. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

August 29, 2005

(Campaign #: C0539)

ENGINE STALL CONDITION

CERTAIN CUMMINS ISB-02 DIESEL ENGINES EQUIPPED WITH EMC CONTROLLED FUEL LIFT PUMPS. ERRATIC VOLTAGE SUPPLY TO THE FUEL LIFT PUMP CAUSES PREMATURE ELECTRIC BRUSH WEAR INTERNAL TO THE FUEL LIFT PUMP. THIS PREMATURE WEAR COULD RESULT IN FUEL LIFT PUMP FAILURE AND IN SOME CASES MAY CAUSE AN ENGINE STALL CONDITION.

NHTSA ID: 05E054000

Component: FUEL SYSTEM, OTHER

# of Units Affected: 2,860

Consequence Summary:

SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.

Corrective Action:

CUMMINS WILL NOTIFY OWNERS AND REPAIR THE ENGINES BY EMC RECALIBRATION AND REPLACEMENT OF THE FUEL LIFT PUMP AT NO CHARGE TO THE CUSTOMER. THE RECALL BEGAN ON OCTOBER 3, 2005. OWNERS MAY CONTACT CUMMINS ASSISTANCE CENTER AT 1-800-DIESELS.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

February 2, 2005

(Campaign #: NR (Not Reported))

CUMMINS/FUEL LIFT PUMP/ENGINE STALLING

CERTAIN CUMMINS ISB DIESEL ENGINES EQUIPPED WITH FEDERAL-MOGAL 12 AND 24 VOLT FUEL LIFT PUMPS FOR USE IN CERTAIN SCHOOL BUSES, TRANSIT BUSES, AND EMERGENCY VEHICLES. THE FUEL PUMP COULD FAIL TO TRANSFER FUEL APPROPRIATELY CREATING AN ENGINE STALL CONDITION.

NHTSA ID: 05E007000

Component:

# of Units Affected: 35,219

Consequence Summary:

SHOULD THE ENGINE STALL WHILE THE VEHICLE IS IN USE, A POSSIBLE VEHICLE CRASH COULD OCCUR.

Corrective Action:

CUSTOMERS WILL BE NOTIFIED BY CUMMINS TO BRING THEIR VEHICLES TO AN AUTHORIZED DEALER TO HAVE THE FUEL LIFT PUMP REPLACED FREE OF CHARGE. THE RECALL BEGAN ON JUNE 30, 2005. OWNERS MAY CONTACT CUMMINS AT 1-800-DIESELS.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details