Collins Bus Corporation: Safety Recalls in 2005
Updated on March 19, 2026.
There were 6 safety recalls made by Collins Bus Corporation in 2005. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
September 29, 2005
(Campaign #: NR (Not Reported))
FMVSS 210 AND 222 - SEAT FASTENERS
CERTAIN 2005 COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES AND SUPER OMNI BUSES BUILT BETWEEN AUGUST 1 AND SEPTEMBER 15, 2005. THE FASTENERS SECURING THE SEATS AND THE BARRIERS TO THE WALL TRACK MAY BE INADEQUATELY TIGHTENED WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, SEAT BELT ASSEMBLY ANCHORAGES AND FMVSS NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.
NHTSA ID: 05V440000
Component:
# of Units Affected: 150
Consequence Summary:
IN THE EVENT OF A CRASH, THE SEAT OCCUPANTS MAY NOT BE ADEQUATELY PROTECTED, POSSIBLY RESULTING IN SERIOUS INJURIES.
Corrective Action:
COLLINS WILL NOTIFY THE BUS OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 23, 2005. OWNERS MAY CONTACT COLLINS AT 620-662-9000 OR 800-533-1850 X430.
Park Outside Advisory: No
Do not Drive Advisory: No
August 15, 2005
(Campaign #: NR (Not Reported))
FMVSS 221/JOINT STRENGTH
CERTAIN 2004 MY BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN JULY 2004 AND NOVEMBER 2004. THE AMOUNT OF ADHESIVE APPLIED TO THE ROOF SEAMS IS INADEQUATE FOR THE TYPE OF ADHESIVE USED WHICH FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 221, SCHOOL BUS BODY JOINT STRENGTH.
NHTSA ID: 05V359000
Component: STRUCTURE
# of Units Affected: 201
Consequence Summary:
IN THE EVENT OF A CRASH, THE JOINTS MAY COME APART AND INDIVIDUAL INTERIOR CEILING SKINS COULD CAUSE HARM TO THE OCCUPANTS OF THE BUS.
Corrective Action:
DEALERS WILL CORRECT THE BUSES BY ADDING TWO ADDITIONAL SCREWS BETWEEN THE CURRENT SCREWS THAT ATTACH THE SEAMS OF THE CEILING SKINS TO THE STRUCTURAL ROOF BOWS. THE RECALL BEGAN ON DECEMBER 14, 2005. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.
Park Outside Advisory: No
Do not Drive Advisory: No
August 1, 2005
(Campaign #: NR (Not Reported))
STOP ARM MALFUNCTIONS
CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH SPECIALTY MFG "5" SERIES STOP ARMS ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE FOLLOWING STATES: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
NHTSA ID: 05V343000
Component: OTHER
# of Units Affected: 1,345
Consequence Summary:
SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
Corrective Action:
COLLINS BUS WILL NOTIFY ITS CUSTOMERS AND THE ORIGINAL SWITCH WILL BE REPLACED FREE OF CHARGE WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED FREE OF CHARGE. THE RECALL BEGAN OCTOBER 12, 2005. CUSTOMERS MAY CONTACT COLLINS BUS CUSTOMER SERVICE AT 1-800-533-1850 OR SPECIALTY MANUFACTURING AT 1-800-951-7867.
Park Outside Advisory: No
Do not Drive Advisory: No
August 1, 2005
(Campaign #: NR (Not Reported))
STOP ARM MALFUNCTIONS
CERTAIN 2002-2005 MY COLLINS BANTAM, SUPER BANTAM, AND GRAND BANTAM SCHOOL BUSES EQUIPPED WITH "5" SERIES STOP ARMS. THESE SCHOOL BUSES WERE ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN STATES OTHER THAN THE FOLLOWING: ALASKA, COLORADO, CONNECTICUT, DELAWARE, IDAHO, ILLINOIS, INDIANA, IOWA, KANSAS, KENTUCKY, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW JERSEY, NEW MEXICO, NEW YORK, NORTH DAKOTA, OHIO, OREGON, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WASHINGTON, WEST VIRGINIA, WISCONSIN, WYOMING, AND THE DISTRICT OF COLUMBIA. IN EXTREMELY COLD WEATHER, THE MICROSWITCHES USED INTERNALLY TO POSITION THE SIGN IN THE OPEN AND CLOSED POSITIONS MAY MALFUNCTION, CAUSING THE SIGN TO OPEN OR CLOSE IN AN IMPROPER POSITION, OR TO NOT OPEN AT ALL.
NHTSA ID: 05V345000
Component: OTHER
# of Units Affected: 687
Consequence Summary:
SHOULD THE STOP ARM NOT PERFORM PROPERLY, A CHILD OR PEDESTRIAN MAY BE ENDANGERED BY PASSING VEHICLES SHOULD THE MOTORIST NOT STOP AT THE CORRECT LOCATION.
Corrective Action:
COLLINS WILL NOTIFY ALL ITS CUSTOMERS OF THIS CAMPAIGN. FOR THOSE BUSES OPERATED IN OR NEAR ANY OF THE STATES LISTED ABOVE, COLLINS IS ENCOURAGING THE BUS OWNERS TO OBTAIN THE REPLACEMENT SWITCH. FOR THOSE BUSES OPERATED IN THE WARMER STATES, COLLINS WILL REPLACE THE SWITCH UPON OWNER REQUEST. FOR THOSE CUSTOMERS WHO REQUEST THE REMEDY, COLLINS WILL REPLACE THE ORIGINAL SWITCH WITH A SWITCH PACK THAT IS NOT SENSITIVE TO EXTREME COLD WEATHER AND WILL INSPECT TO ENSURE THE MICROSWITCH HEATER WIRING IS PROPERLY CONNECTED. THE SAFETY IMPROVEMENT CAMPAIGN BEGAN OCTOBER 12, 2005. OWNERS MAY CONTACT COLLINS AT 800-448-7825 OR SPECIALTY MANUFACTURING AT 1-800-951-7867.
Park Outside Advisory: No
Do not Drive Advisory: No
May 2, 2005
(Campaign #: NR (Not Reported))
FMVSS 222/SEAT CUSHION IS TOO WIDE
CERTAIN COLLINS MY 2002-2005 BANTAM, SUPER BANTAM, AND GRAND BANTAM MODEL SCHOOL BUSES MANUFACTURED BETWEEN APRIL 22, 2002, AND APRIL 27, 2005. THESE BUSES WERE EQUIPPED WITH A BENCH-STYLE SINGLE PASSENGER SEATS HAVING A LOWER CUSHION SURFACE OF 24 INCHES IN WIDTH. THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES FOR A SIGNAL DESIGNATED SEATING POSITION. THESE SEATS DO NOT CONFORM TO FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 222, SCHOOL BUS PASSENGER SEATING AND CRASH PROTECTION.
NHTSA ID: 05V192000
Component:
# of Units Affected: 272
Consequence Summary:
THESE SEATS SHOULD HAVE A SEATING SURFACE OF ONLY 22 INCHES WIDE TO HAVE A SINGLE DESIGNATED SEATING POSITION. BECAUSE THE 24 INCH CUSHION IS WIDER THAN 22 INCHES, THE POTENTIAL EXISTS FOR TWO PASSENGERS TO BE SEATED IN THIS SEAT. A SECOND PASSENGER WOULD NOT HAVE AN AVAILABLE SEAT BELT FOR RESTRAINT AND MAY BE INJURED IN A CRASH.
Corrective Action:
COLLINS WILL NOTIFY ITS CUSTOMERS AND REPLACE THE 24 INCH SEAT CUSHION WITH A 22 INCH SEAT CUSHION FREE OF CHARGE. THE RECALL BEGAN APRIL 29, 2005. OWNERS MAY CONTACT COLLINS CUSTOMER SERVICE AT 1-800-533-1850.
Park Outside Advisory: No
Do not Drive Advisory: No
January 21, 2005
(Campaign #: NR (Not Reported))
FUEL LEAKS
CERTAIN 2002 THRU 2005 COLLINS BANTAM AND SUPER BANTAM SCHOOL BUSES MANUFACTURED BETWEEN SEPTEMBER 18, 2002, AND JANUARY 17, 2005. THE PROTECTIVE RUBBER PARTS THAT COVER THE FUEL LINES TO PREVENT CONTACT WITH METAL EDGES MAY BE MISSING.
NHTSA ID: 05V011000
Component: FUEL SYSTEM, OTHER
# of Units Affected: 108
Consequence Summary:
THE FUEL LINES MAY BE CUT RESULTING IN FUEL SPILLAGE AND IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Corrective Action:
CUSTOMERS WILL BE NOTIFIED TO TAKE THEIR BUSES TO AN AUTHORIZED DEALER FOR FREE REPAIR. DEALERS WILL INSPECT THE FUEL LINES AND INSTALL THE PROTECTIVE RUBBER COVERING SHOULD IT BE MISSING. IF THE FUEL LINES ARE DAMAGED, DEALERS WILL REPLACE THE FUEL LINES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 21, 2005. OWNERS MAY CONTACT COLLINS AT 1-800-533-1850.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.