Coachmen RV Company, LLC: Safety Recalls in 2007
Updated on March 19, 2026.
There were 5 safety recalls made by Coachmen RV Company, LLC in 2007. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
November 21, 2007
(Campaign #: NR (Not Reported))
SLIDEOUT IGNITION CONNECTOR
ON CERTAIN CLASS C MINI-MOTOR HOMES, THE 12 VOLT SLIDEROOM WIRE CONNECTION TO THE CHASSIS IGNITION SYSTEM MAY BE WIRED INCORRECTLY CAUSING THE BRAKE ON THE SLIDEROOM MOTOR TO DISENGAGE WHEN THE IGNITION IS IN THE 'ON' OR 'RUN' POSITION. THIS COULD CAUSE THE SLIDEROOM TO 'RELAX' AND POSSIBLY MOVE TO THE OUT POSITION WHILE IN TRANSIT IF THE TRAVEL LOCKS PROVIDED WITH THE VEHICLE ARE NOT INSTALLED AS RECOMMENDED.
NHTSA ID: 07V539000
Component: ELECTRICAL SYSTEM
# of Units Affected: 395
Consequence Summary:
SHOULD THE SLIDEROOM EXTEND WHILE THE VEHICLE IS IN MOTION, A CRASH COULD OCCUR.
Corrective Action:
DEALERS WILL PROPERLY WIRE THE SLIDEROOM MOTOR BRAKE ACTIVATION SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 20, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
October 16, 2007
(Campaign #: NR (Not Reported))
SPARE TIRE CARRIER
ON CERTAIN MOTOR HOMES, THE SPARE TIRE CARRIER ASSEMBLY MOUNTED UNDER THE REAR OF THE UNIT IS THE INCORRECT MODEL TO PROPERLY SUPPORT THE SPARE TIRE.
NHTSA ID: 07V483000
Component: TIRES
# of Units Affected: 193
Consequence Summary:
AS A RESULT, THE POTENTIAL EXISTS FOR THE SPARE TIRE TO BECOME DETACHED FROM THE CARRIER ASSEMBLY AND FALL TO THE ROAD SURFACE. SHOULD THE SPARE TIRE DETACH ITSELF FROM THE CARRIER WHILE THE VEHICLE IS IN MOTION, A CRASH MAY RESULT.
Corrective Action:
DEALERS WILL INSTALL THE CORRECT SPARE TIRE SYSTEM AND ALSO A SECONDARY MECHANICAL BACK-UP LATCH. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
August 7, 2007
(Campaign #: NR (Not Reported))
CONNECTING ROD FAILURE/CUMMINS
ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.
NHTSA ID: 07V341000
Component: ENGINE AND ENGINE COOLING
# of Units Affected: 49
Consequence Summary:
IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.
Corrective Action:
COACHMEN IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR COACHMEN AT 1-574-825-8528.
Park Outside Advisory: No
Do not Drive Advisory: No
May 9, 2007
(Campaign #: NR (Not Reported))
PART 567/FMVSS 110/CERTIFICATION & TIRE LABEL
CERTAIN TRAVEL TRAILERS FAIL TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION," AND FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE INFORMATION PROVIDED ON THE CERTIFICATION AND TIRE INFORMATION LABELS DENOTING THE TIRE PRESSURE IS INCORRECT.
NHTSA ID: 07V200000
Component: EQUIPMENT
# of Units Affected: 230
Consequence Summary:
SHOULD THE TIRES BE INFLATED TO THE INCORRECT PRESSURE, IT IS POSSIBLE THAT THE TIRES COULD BE OVERLOADED AND FAIL, INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSTALL THE CORRECT CERTIFICATION AND TIRE INFORMATION LABELS AND SET THE TIRE PRESSURE TO THE REQUIRED 65 PSI FREE OF CHARGE. THE RECALL BEGAN ON MAY 21, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
March 7, 2007
(Campaign #: NR (Not Reported))
LP BOTTLE TRAY MOUNTING SCREWS
ON CERTAIN TRAVEL TRAILERS, THE SELF TAPING SCREWS THAT ARE USED TO SECURE THE LIQUID PROPANE (LP) BOTTLE SUPPORT TRAY TO THE TRAILER FRAME MAY FAIL. THE SUPPORT TRAY IS MOUNTED TO THE A-FRAME OF THE TRAILER AND HOLDS THE LP BOTTLES SECURELY IN PLACE.
NHTSA ID: 07V084000
Component: EQUIPMENT
# of Units Affected: 24
Consequence Summary:
SHOULD THESE SCREWS FAIL, THE LP BOTTLES COULD COME LOOSE, DISENGAGE FROM THE TRAILER INCREASING THE RISK OF A CRASH. IF SIGNIFICANT CONTACT WERE TO OCCUR OVER A PERIOD OF TIME, THE LP TANK OR LINES COULD BE DAMAGED AND POTENTIALLY LEAK LP GAS, WHICH COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL REPAIR THE LP BOTTLE TRAY FREE OF CHARGE. THE RECALL BEGAN ON MARCH 19, 2007. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.