Coachmen RV Company, LLC: Safety Recalls in 2006
Updated on March 19, 2026.
There were 6 safety recalls made by Coachmen RV Company, LLC in 2006. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
November 7, 2006
(Campaign #: NR (Not Reported))
REFRIGERATOR/DOMETIC
ON CERTAIN RECREATIONAL VEHICLES BUILT WITH DOMETIC TWO-DOOR REFRIGERATORS, A FATIGUE CRACK MAY DEVELOP IN THE BOILER TUBE IN THE AREA OF THE WELD BETWEEN THE BOILER TUBE AND THE HEATER POCKET. A FATIGUE CRACK MAY RELEASE A SUFFICIENT AMOUNT OF PRESSURIZED COOLANT SOLUTION INTO AN AREA WHERE AN IGNITION SOURCE IS PRESENT.
NHTSA ID: 06V430000
Component: EQUIPMENT
# of Units Affected: 9,845
Consequence Summary:
THE RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Corrective Action:
COACHMEN IS WORKING WITH DOMETIC TO HAVE THESE REFRIGERATORS REPAIRED. THE MANUFACTURER HAS NOT YET SUBMITTED AN OWNER NOTIFICATION SCHEDULE FOR THIS CAMPAIGN. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821 OR DOMETIC/STERICYCLE AT 1-888-446-5157.
Park Outside Advisory: No
Do not Drive Advisory: No
September 18, 2006
(Campaign #: NR (Not Reported))
TIRE CERTIFICATION LABEL/FMVSS 110
CERTAIN MOTOR HOMES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THE INFORMATION PROVIDED ON THE CERTIFICATION AND TIRE INFORMATION LABELS DENOTING THE TIRE SIZE IS INCORRECT.
NHTSA ID: 06V365000
Component: EQUIPMENT
# of Units Affected: 61
Consequence Summary:
A MISPRINTED LABEL WOULD LEAD TO IMPROPER VEHICLE LOADING SPECIFICATIONS OR TIRE INFLATION WHICH COULD RESULT IN A TIRE FAILURE, INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE CERTIFICATION AND TIRE INFORMATION LABELS WITH THE CORRECT LABELS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 9, 2006. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
September 13, 2006
(Campaign #: NR (Not Reported))
FUEL RAIL DAMPER RETAINER CLIP/WORKHORSE
ON CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS AND EQUIPPED WITH GM 8.1L V8 ENGINES, IMPROPER HARDENING DURING THE HEAT TREATMENT PROCESS CAN CAUSE THE FUEL RAIL PULSE DAMPER RETAINER CLIP TO FRACTURE, RESULTING IN INADEQUATE RETENTION OF THE DAMPER. IF THE DAMPER BECOMES LOOSE, FUEL COULD BE PUMPED BY THE FUEL PUMP INTO THE UNDER HOOD AREA.
NHTSA ID: 06V352000
Component:
# of Units Affected: 1,332
Consequence Summary:
IN THE PRESENCE OF AN IGNITION SOURCE, A FIRE COULD RESULT.
Corrective Action:
WORKHORSE IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN (PLEASE SEE 06V225). DEALERS WILL REPLACE THE FUEL RAIL PULSE DAMPER RETAINER CLIPS ON THESE ENGINES FREE OF CHARGE. OWNERS MAY CONTACT WORKHORSE AT 877-294-6773 OR COACHMAN AT 219-825-8528.
Park Outside Advisory: No
Do not Drive Advisory: No
July 19, 2006
(Campaign #: NR (Not Reported))
OVERHEAD TV CABINET
ON CERTAIN MOTOR HOMES, THE CABINET CONTAINING THE TELEVISION SET THAT IS INSTALLED IN THE OVERHEAD COCKPIT MAY BE INADEQUATELY SECURED.
NHTSA ID: 06V267000
Component: EQUIPMENT
# of Units Affected: 1,485
Consequence Summary:
SHOULD THE CABINET FASTENERS FAIL, THE OVERHEAD TELEVISION CABINET AND TELEVISION SET MAY FALL AND COULD CONTACT THE WINDSHIELD, DRIVER, OR PASSENGER INCREASING THE RISK OF A CRASH OR PERSONAL INJURY.
Corrective Action:
DEALERS WILL INSPECT THE CABINETS AND MAKE THE NECESSARY REPAIRS. THE RECALL BEGAN ON JULY 24, 2006. OWNERS MAY CONTACT COACHMEN AT 1-574-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
June 21, 2006
(Campaign #: NR (Not Reported))
STEERING INTERMEDIATE SHAFT/WORKHORSE
CERTAIN MOTOR HOMES BUILT ON WORKHORSE CHASSIS MAY HAVE BEEN EQUIPPED WITH INCORRECT STEERING INTERMEDIATE SHAFTS. THE SPLINE CAN STRIP WHILE THE STEERING WHEEL IS BEING TURNED.
NHTSA ID: 06V224000
Component:
# of Units Affected: 32
Consequence Summary:
THIS STEERING CONDITION COULD RESULT IN A LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
Corrective Action:
WORKHORSE IS CONDUCTING THIS RECALL (PLEASE SEE 06V148000) AND WILL INSPECT AND, IF NECESSARY, REPLACE THE STEERING INTERMEDIATE SHAFT. OWNERS MAY CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 574-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
April 13, 2006
(Campaign #: NR (Not Reported))
BATTERY CABLES
ON CERTAIN MOTOR HOMES, THE BATTERY CABLES THAT EXIT THE REAR OF THE BATTERY STORAGE COMPARTMENT ARE NOT ADEQUATELY SECURED. SHOULD THE CABLES BECOME UNSECURED, THEY COULD COME IN DIRECT CONTACT WITH THE ENGINE EXHAUST SYSTEM.
NHTSA ID: 06V118000
Component: ELECTRICAL SYSTEM
# of Units Affected: 29
Consequence Summary:
IN THE EVENT THAT THE CABLES COME IN CONTACT WITH THE EXHAUST SYSTEM, THE CABLE PROTECTIVE COVERING COULD EVENTUALLY MELT CAUSING A DIRECT SHORT IN THE 12-VOLT ELECTRICAL SYSTEM, WHICH COULD RESULT IN A FIRE.
Corrective Action:
DEALERS WILL USE A TUBE CLAMP TO SECURE THE EXCESS LENGTH OF WIRE TO A STEEL TRUSS MEMBER ABOVE AND OUT OF THE WAY OF THE EXHAUST AND WILL ALSO ADD A HEAT SHIELD. THE RECALL BEGAN ON APRIL 10, 2006. OWNERS MAY CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.