Coachmen RV Company, LLC: Safety Recalls in 2004
Updated on March 19, 2026.
There were 5 safety recalls made by Coachmen RV Company, LLC in 2004. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
October 28, 2004
(Campaign #: 04S23)
COACHMEN/FORD/AIR FILTER ELEMENT
ON MOTOR HOMES BUILT ON FORD E-SERIES CHASSIS, THE AIR FILTER ELEMENT MATERIAL PROCESS RESULTED IN AN AIR FILTER PAPER ELEMENT THAT CAN SMOLDER OR BURN. THIS CHANGE IN FILTER PAPER COMPOSITION COMBINED WITH THE CONFIGURATION OF THE AIR INDUCTION SYSTEM, MAY ALLOW HOT CARBON PARTICLES TO CONTACT THE AIR FILTER ELEMENT DURING CERTAIN DRIVING CONDITIONS THAT CREATE HOT PARTICLES.
NHTSA ID: 04V515000
Component:
# of Units Affected: 88
Consequence Summary:
THESE HOT PARTICLES MAY IGNITE THE AIR FILTER ELEMENT WITH THE POTENTIAL FOR AIR INDUCTION SYSTEM DAMAGE OR UNDERHOOD FIRE.
Corrective Action:
FORD IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL INSPECT AND REPLACE THE AIR FILTER ELEMENT. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673 OR COACHMEN AT 219-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
October 27, 2004
(Campaign #: NR (Not Reported))
COACHMEN/WORKHORSE/BOSCH/BRAKE CALIPER
ON MOTOR HOME CHASSIS BUILT BY WORKHORSE AND EQUIPPED WITH BOSCH BRAKES, THE PADS CAN DRAG ON THE ROTOR SURFACE DUE TO THE PIN SLIDE.
NHTSA ID: 04V518000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 238
Consequence Summary:
A HANG UP OR LOCK UP MAY CAUSE THE CALIPERS TO OVER HEAT AND NOT ALLOW THE DRIVER TO STOP SAFELY. THIS COULD CAUSE OVERHEATING OF THE BRAKE CALIPERS WHICH COULD RESULT IN A VEHICLE FIRE.
Corrective Action:
WORKHORSE IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPAIR THE BRAKE CALIPER. OWNERS SHOULD CONTACT WORKHORSE AT 1-877-294-6773 OR COACHMEN AT 219-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
April 5, 2004
(Campaign #: NR (Not Reported))
COACHMEN/LP TANK
ON CERTAIN MOTORHOMES, THE CHASSIS LEAF SPRING REAR SHACKLE AND/OR SHACKLE BOLT COULD COME IN DIRECT CONTACT WITH THE LP TANK WHEN THE VEHICLE IS IN MOTION.
NHTSA ID: 04V160000
Component: SUSPENSION
# of Units Affected: 120
Consequence Summary:
THIS COULD CAUSE THE LP TANK TO BECOME DAMAGED AND POTENTIALLY LEAK INCREASING THE RISK OF A FIRE.
Corrective Action:
DEALERS WILL MOVE THE MOUNTING LOCATION OF THE TANK OUT OF THE CHASSIS RAILS, AWAY FROM THE CHASSIS LEAF SPRING REAR SHACKLE. OWNER NOTIFICATION BEGAN ON APRIL 12, 2004. OWNERS SHOULD CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
March 8, 2004
(Campaign #: NR (Not Reported))
COACHMEN/REFRIGERATOR WIRING HARNESS
ON CERTAIN CLASS C MINI-MOTORHOMES, THE WIRING HARNESS ROUTED BETWEEN THE BACK OF THE REFRIGERATOR AND THE REFRIGERATOR CABINET COULD COME IN DIRECT CONTACT WITH THE REFRIGERATOR BURNER TUBE AND COOLING UNIT.
NHTSA ID: 04V119000
Component: EQUIPMENT
# of Units Affected: 122
Consequence Summary:
IF CONTACT OCCURS, THE WIRE INSULATION MATERIAL MAY MELT, DUE TO THE OPERATING TEMPERATURE OF THE BURNER TUBE AND COOLING UNIT WHICH COULD LEAD TO A FIRE.
Corrective Action:
DEALERS WILL RELOCATE THE WIRE HARNESS. THE RECALL BEGAON ON MARCH 29, 2004. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
January 8, 2004
(Campaign #: NR (Not Reported))
COACHMEN/SPARTAN/HYDRAULIC PUMP
ON CERTAIN MOTORHOMES BUILT ON SPARTAN CHASSIS, THE ANGLE OF THE HOSES FROM THE HYDRAULIC PUMP COULD CONTACT THE POSITIVE STUD ON THE STARTER.
NHTSA ID: 04V022000
Component: STEERING
# of Units Affected: 2
Consequence Summary:
THIS COULD RESULT IN CLOSE CONTACT WITH THE STARTER AND CAUSE IGNITION OF HYDRAULIC FLUID WHICH COULD RESULT IN INJURY AND/OR PROPERTY DAMAGE.
Corrective Action:
SPARTAN IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPLACE ON VEHICLES WITH CUMMINS ISL ENGINES AND 39MT DELCO STARTERS AT LEAST ONE OF THE 45 DEGREE FITTINGS WITH A 90 DEGREE FITTING AND ALSO REPLACE THE HOSE ASSEMBLY. ON ISL AND ISC ENGINES WITH 42MT DELCO STARTER, DEALERS WILL CHANGE ONE FITTING AT THE REAR OF THE HYDRAULIC PUMP AND RE-ROUTE A HOSE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SPARTAN AT 1-219-825-5821 OR COACHMEN AT 1-517-543-6400.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.