Coachmen RV Company, LLC: Safety Recalls in 2003
Updated on March 19, 2026.
There were 6 safety recalls made by Coachmen RV Company, LLC in 2003. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
October 14, 2003
(Campaign #: NR (Not Reported))
COACHMEN/SAMSUNG/MICROWAVES
ON CERTAIN MOTOR HOMES, TRAVEL TRAILERS, AND FIFTH WHEEL TRAILERS EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
NHTSA ID: 03V373000
Component: EQUIPMENT
# of Units Affected: 19,110
Consequence Summary:
AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
Corrective Action:
SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR COACHMEN AT 1-219-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
September 12, 2003
(Campaign #: NR (Not Reported))
COACHMEN/FRONT SUSPENSION SEPARATION
ON CERTAIN MOTORHOMES EQUIPPED WITH TUTHILL INDEPENDENT FRONT SUSPENSIONS, THE DEFECT IS INSUFFICIENT TIGHTENING TORQUE OF THE STEERING KNUCKLE CARRIER BOLT THAT MAY RESULT IN SEPARATION OF THE STEERING KNUCKLE FROM ONE OF THE CONTROL ARMS.
NHTSA ID: 03V342000
Component: SUSPENSION
# of Units Affected: 27
Consequence Summary:
SHOULD THE STEERING KNUCKLE CARRIER SEPARATE FROM THE CONTROL ARM, THE OPERATOR COULD LOOSE CONTROL OF THE VEHICLE, POSSIBLY RESULTING IN A CRASH.
Corrective Action:
TUTHILL WILL NOTIFY ITS CUSTOMERS AND PROVIDE A RETROFIT KIT P/N K704627 FREE OF CHARGE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TUTHILL TRANSPORT TECHNOLOGIES AT 800-225-7824 (EXT. #390), SPARTAN AT 517-543-6400, OR COACHMEN AT 574-825-8525.
Park Outside Advisory: No
Do not Drive Advisory: No
April 9, 2003
(Campaign #: NR (Not Reported))
COACHMEN/SLIDE-IN ROOM
ON CERTAIN MOTOR HOMES. THE FRAME EXTRUSION AT THE BASE OF THE KITCHEN SLIDE ROOM, THAT SERVES TO MAINTAIN THE LOCKING MECHANISM FOR THE SLIDE ROOM, MAY BECOME LOOSE FROM THE BODY OF THE VEHICLE. WHEN THIS OCCURS, THE LOCKING MECHANISM IS RENDERED INEFFECTIVE AND THE SLIDE ROOM CAN OPEN UNEXPECTEDLY.
NHTSA ID: 03V134000
Component: EQUIPMENT
# of Units Affected: 79
Consequence Summary:
SHOULD THIS OCCUR WHILE THE VEHICLE IS IN MOTION, THE POTENTIAL EXISTS FOR A CRASH.
Corrective Action:
DEALERS WILL INSTALL LONGER SELF-TAPPING SCREWS TO ENSURE THE EXTRUSION IS SECURED TO THE STEEL FRAMING. IN ADDITION, "TRAVEL LOCKS" THAT, WHILE IN PLACE, PREVENT THE SLIDE ROOM FROM MOVING OUT UNDER ANY CIRCUMSTANCES WILL BE SUPPLIED WITH ALL UNITS. OWNER NOTIFICATION BEGAN ON APRIL 28, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
March 10, 2003
(Campaign #: NR (Not Reported))
COACHMEN/FUEL RETURN LINE
ON CERTAIN CLASS C MINI-MOTOR HOMES BUILT ON 2003 CHEVROLET CHASSIS, THE CHASSIS FUEL RETURN LINE, WHICH IS TAPPED TO SUPPLY FUEL TO THE GENERATOR, HAS BEEN FOUND TO HAVE PRESSURES THAT EXCEED THE MAXIMUM ALLOWED BY THE GENERATOR MANUFACTURER.
NHTSA ID: 03V065000
Component: FUEL SYSTEM, GASOLINE
# of Units Affected: 135
Consequence Summary:
AS A RESULT, IF THE GENERATOR IS OPERATED AT THE SAME TIME THE CHASSIS ENGINE IS RUNNING, EXCESS FUEL COULD BE DELIVERED TO THE GENERATOR, CREATING A POTENTIAL FOR A GENERATOR STALL AND POSSIBLE FUEL SPILL. IN THE EVENT OF A FUEL SPILL, A FIRE COULD OCCUR.
Corrective Action:
DEALERS WILL INSTALL AN APPROVED KIT THAT DRAWS THE GENERATOR FUEL SUPPLY DIRECTLY FROM THE FUEL TANK. OWNER NOTIFICATION IS BEGAN MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
March 5, 2003
(Campaign #: NR (Not Reported))
COACHMEN/GENERATOR EXHAUST PIPE
ON CERTAIN CLASS C MINI-MOTOR HOMES, THE GENERATOR EXHAUST PIPE MAY HAVE BEEN ASSEMBLED AND INSTALLED INCORRECTLY RESULTING IN INSUFFICIENT CLEARANCE TO OR CONTACT WITH THE CHASSIS FUEL FILL TUBE.
NHTSA ID: 03V081000
Component: ELECTRICAL SYSTEM
# of Units Affected: 109
Consequence Summary:
WHEN OPERATING, THE GENERATOR'S EXHAUST PIPE MAY REACH TEMPERATURES THAT COULD POTENTIALLY MELT AND/OR IGNITE THE FUEL FILL TUBE. SHOULD THIS OCCUR, THE POTENTIAL EXISTS FOR A FIRE.
Corrective Action:
DEALERS WILL DISASSEMBLE A PORTION OF THE GENERATOR EXHAUST PIPE ASSEMBLY, TURNING ONE OF THE BENT COMPONENTS AROUND 180 DEGREES, REASSEMBLING THE EXHAUST PIPE AND MEASURING TO ENSURE A MINIMUM OF 3" AIR GAP WITH SURROUNDING COMPONENTS. OWNER NOTIFICATION BEGAN MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-800-453-6064.
Park Outside Advisory: No
Do not Drive Advisory: No
February 10, 2003
(Campaign #: NR (Not Reported))
COACHMEN/BRAKE SYSTEM WARNING INDICATOR
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
NHTSA ID: 03V040000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 3,539
Consequence Summary:
IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Corrective Action:
DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNER NOTIFICATION BEGAN MARCH 24, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COACHMEN AT 1-219-825-5821.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.