Chrysler (FCA US, LLC): Safety Recalls in 2010
Updated on March 19, 2026.
There were 17 safety recalls made by Chrysler (FCA US, LLC) in 2010. See the details of the recalls below.
You can also see similar information for other manufacturers.
Data Source: NHTSA.
December 24, 2010
(Campaign #: K28)
TIE ROD ENDS
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008-2011 DODGE RAM 4500 AND 5500 VEHICLES. THESE VEHICLES MAY EXPERIENCE A WEAKENING AND FRACTURE OF THE LEFT BALL STUD ON THE TIE ROD RESULTING IN THE POTENTIAL LOSS OF STEERING.
NHTSA ID: 10V657000
Component: STEERING
# of Units Affected: 15,271
Consequence Summary:
LOSS OF STEERING CONTROL OF THE VEHICLE COULD INCREASE THE RISK OF A CRASH.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT OUTER TIE ROD FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
December 24, 2010
(Campaign #: K07)
FRONT DOOR WIRING
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2009 DODGE JOURNEY VEHICLES MANUFACTURER FROM NOVEMBER 1, 2007, THROUGH NOVEMBER 7, 2008. THE WIRES WITHIN THE FRONT DOOR WIRE HARNESSES MAY FATIGUE AND BREAK, WHICH CAN INTERRUPT THE CIRCUITS FOR THE SIDE IMPACT SENSOR(S), RESULTING IN AN AIRBAG WARNING LAMP ILLUMINATION AND LOSS OF SIDE CRASH SENSING CAPABILITY.
NHTSA ID: 10V658000
Component: ELECTRICAL SYSTEM
# of Units Affected: 64,934
Consequence Summary:
IN THE EVENT OF A CRASH, THE SIDE AIRBAG MAY NOT DEPLOY, REDUCING THE PROTECTION INTENDED FOR THE OCCUPANT AND INCREASING THE RISK OF INJURIES.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND REPLACE THE LEFT AND RIGHT DOOR WIRING HARNESSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 18, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
December 24, 2010
(Campaign #: K36)
REAR AXLE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 RAM 1500 TRUCKS MANUFACTURED FROM SEPTEMBER 2009 THROUGH DECEMBER 2010. SOME VEHICLES MAY HAVE EXPERIENCE A NOISE (GROWL, GRIND) COMING FROM THE REAR AXLE BEARING WHICH COULD EVENTUALLY SEIZE.
NHTSA ID: 10V656000
Component: SUSPENSION
# of Units Affected: 60,382
Consequence Summary:
A FAILURE OF THE BEARING COULD CAUSE THE VEHICLE TO STALL INCREASING THE RISK OF A CRASH.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND WILL INSTALL AN OIL PORT INSERT INTO THE REAR AXLE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 4, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
December 8, 2010
(Campaign #: K25)
HVAC DRAIN GROMMET
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
NHTSA ID: 10V611000
Component: EQUIPMENT
# of Units Affected: 299,635
Consequence Summary:
AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Corrective Action:
DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
December 7, 2010
(Campaign #: K33)
POWER STEERING FLUID RESERVOIR CAP
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010-2011 DODGE RAM TRUCKS MANUFACTURED FROM MARCH 2009 THROUGH OCTOBER 2010. SOME VEHICLES EQUIPPED WITH DIESEL ENGINE AND A HYDROBOOST BRAKE SYSTEM MAY BE EQUIPPED WITH A POWER STEERING RESERVOIR CAP WITH EXCESSIVE VENT PRESSURE LEVELS THAT MAY RESULT IN BRAKE PEDALS THAT ARE SLOW TO RETURN.
NHTSA ID: 10V616000
Component: STEERING
# of Units Affected: 62,166
Consequence Summary:
BRAKE LIGHTS THAT ARE SLOW TO EXTINGUISH COULD INCREASE THE RISK OF A CRASH.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE POWER STEERING RESERVOIR CAP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
November 3, 2010
(Campaign #: K24)
WINDSHIELD WIPER MOTOR
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 JEEP LIBERTY VEHICLES. THE VEHICLES ARE EQUIPPED WITH WINDSHIELD WIPER MOTORS THAT CONTAIN EXCESS ADHESIVE THAT MAY ALLOW FOR WATER INTRUSION, WHICH COULD RESULT IN INTERMITTENT AND EVENTUALLY INOPERATIVE WINDSHIELD WIPER OPERATION.
NHTSA ID: 10V550000
Component: VISIBILITY
# of Units Affected: 12,027
Consequence Summary:
A FAILING OR INOPERATIVE WINDSHIELD WIPER SYSTEM WILL REDUCE A DRIVER'S VISIBILITY WHICH COULD RESULT IN A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE WINDSHIELD WIPER MOTOR FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 1, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
October 7, 2010
(Campaign #: K26)
POWER STEERING PRESSURE HOSE ASSEMBLY
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING, 300, CHARGER (LX) AND DODGE CHALLENGER (LC), AVENGER (JS), AND JOURNEY (JC), AS WELL AS MODEL YEAR 2011 DODGE RAM LIGHT DUTY PICKUP (DS) VEHICLES. SOME OF THESE VEHICLES MAY EXPERIENCE A SEPARATION AT THE CRIMPED END OF THE POWER STEERING PRESSURE HOSE ASSEMBLY.
NHTSA ID: 10V475000
Component: STEERING
# of Units Affected: 23,237
Consequence Summary:
LEAKED POWER STEERING FLUID ONTO HOT ENGINE COMPONENTS COULD CAUSE A FIRE.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE AS NECESSARY THE POWER STEERING PRESSURE HOSES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 20, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
October 7, 2010
(Campaign #: K27)
TIRE PRESSURE INFORMATION LABELS
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2011 DODGE RAM D2, DJ, AND DS-BODY VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF PART 567, "CERTIFICATION." SOME VEHICLES HAVE BEEN BUILT WITH CERTIFICATION AND/OR SUPPLEMENTAL TIRE PRESSURE INFORMATION LABELS PRINTED WITH INCORRECT WEIGHT OR SEATING CAPACITY INFORMATION.
NHTSA ID: 10V474000
Component: EQUIPMENT
# of Units Affected: 772
Consequence Summary:
THE MISINFORMATION ON THESE LABELS COULD LEAD TO, AMONG OTHER THINGS, FAILURE TO FOLLOW PROPER VEHICLE LOADING SPECIFICATIONS THAT COULD INCREASE THE RISK OF A CRASH.
Corrective Action:
OWNERS WILL BE PROVIDED WITH REPLACEMENT CERTIFICATION AND/OR SUPPLEMENTAL TIRE PRESSURE INFORMATION LABELS. AT THE CUSTOMER'S OPTION, THEY MAY TAKE THEIR VEHICLE TO A CHRYSLER DEALER FOR INSTALLATION. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON DECEMBER 22, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
July 7, 2010
(Campaign #: NR (Not Reported))
HYDRAULIC CONTROL UNIT/TI AUTOMOTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 LEFT HAND DRIVE JEEP LIBERTY, DODGE NITRO AND RAM 1500 TRUCK; RIGHT AND LEFT HAND DRIVE JEEP WRANGLER VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED MASTER CYLINDER TO HYDRAULIC CONTROL UNIT (HCU) BRAKE TUBE ASSEMBLY END FLARE.
NHTSA ID: 10V315000
Component: SERVICE BRAKES, HYDRAULIC
# of Units Affected: 20,626
Consequence Summary:
THIS COULD LEAD TO LOSS OF BRAKE FLUID AND REDUCED BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL REPLACE THE BRAKE TUBES FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING AUGUST 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2010
(Campaign #: K13)
PARTIAL LOSS OF SERVICE BRAKES
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2007 THROUGH 2010 JEEP WRANGLER LEFT AND RIGHT HAND DRIVE PASSENGER VEHICLES MANUFACTURED FROM MAY 15, 2006 THROUGH APRIL 22, 2010. THERE MAY BE CONTACT BETWEEN THE RIGHT AND LEFT FRONT INNER FENDER LINERS AND THE RIGHT FRONT AND LEFT REAR BRAKE TUBES WHICH COULD CAUSE WEAR OF THE TUBES CAUSING A BRAKE FLUID LEAK.
NHTSA ID: 10V236000
Component:
# of Units Affected: 287,653
Consequence Summary:
A BRAKE FLUID LEAK CAN CAUSE PARTIAL LOSS OF SERVICE BRAKES AT THE AFFECTED WHEEL INCREASING THE RISK OF A CRASH.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2010
(Campaign #: K11)
STICKING OR BINDING ACCELERATOR PEDALS
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2007 DODGE CALIBER AND JEEP COMPASS PASSENGER VEHICLES MANUFACTURED FROM MARCH 7 THROUGH MAY 19, 2006. THE PIVOT BUSHINGS IN VEHICLES WITH OVERSIZED ACCELERATOR PEDAL BEARING POCKETS MAY BECOME DISLODGED AND POTENTIALLY CAUSE THE ACCELERATOR PEDAL TO BIND OR STICK.
NHTSA ID: 10V234000
Component: VEHICLE SPEED CONTROL
# of Units Affected: 24,825
Consequence Summary:
SHOULD THE PEDAL BIND OR BECOME STUCK, IT CAN BE OVERCOME BY SMART BRAKES WHICH OVERRIDE THE ACCELERATOR PEDAL IN CERTAIN CONDITIONS.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL INSPECT AND REPLACE ALL AFFECTED ACCELERATOR PEDAL ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JUNE 29, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
June 3, 2010
(Campaign #: K14)
SLIDING DOOR WIRE TRACK ASSEMBLY/POSSIBLE FIRE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
NHTSA ID: 10V235000
Component: ELECTRICAL SYSTEM
# of Units Affected: 284,655
Consequence Summary:
A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Corrective Action:
CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
May 11, 2010
(Campaign #: K08)
WIRELESS IGNITION NODE MODULE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER 300, DODGE CHALLENGER, CHARGER, JEEP COMMANDER, GRAND CHEROKEE AND DODGE RAM VEHICLES. THESE VEHICLES MAY HAVE BEEN BUILT WITH A WIRELESS IGNITION NODE (WIN) MODULE EXHIBITING A BINDING CONDITION OF THE SOLENOID LATCH.
NHTSA ID: 10V200000
Component: ELECTRICAL SYSTEM
# of Units Affected: 37,335
Consequence Summary:
THE RESULT OF THE DEFECT COULD LEAD TO A CONDITION WHERE THE KEY MAY BE REMOVED FROM THE IGNITION SWITCH (WIN MODULE) PRIOR TO PLACING THE SHIFTER IN PARK. THIS COULD RESULT IN THE POTENTIAL FOR UNINTENDED VEHICLE MOVEMENT AND COULD INCREASE THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE WIN MODULE FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE AUGUST 23, 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
May 11, 2010
(Campaign #: K09)
DOOR LOCK ROD
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 DODGE CALIBER VEHICLES. SOME VEHICLES MAY HAVE BEEN BUILT WITH AN INCORRECT DOOR LOCK ROD IN THE RIGHT FRONT DOOR.
NHTSA ID: 10V197000
Component: LATCHES/LOCKS/LINKAGES
# of Units Affected: 123
Consequence Summary:
AN UNLATCHED DOOR COULD INCREASE THE RISK OF AN UNBELTED FRONT SEAT PASSENGER BEING EJECTED FROM THE VEHICLE.
Corrective Action:
DEALERS WILL INSPECT AND REPLACE THE FRONT RIGHT DOOR LOCK ROD AS REQUIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
March 5, 2010
(Campaign #: K05)
REAR TRACK BAR
CHRYSLER IS RECALLING MODEL YEAR 2010 JEEP COMMANDER AND GRAND CHEROKEE VEHICLES. THEY MAY HAVE BEEN BUILT WITH AN IMPROPERLY MANUFACTURED REAR TRACK BAR.
NHTSA ID: 10V085000
Component:
# of Units Affected: 3,465
Consequence Summary:
REDUCED VEHICLE STABILITY COULD OCCUR INCREASING THE RISK OF A CRASH.
Corrective Action:
DEALERS WILL INSPECT THE REAR TRACK BAR BUSHING RETAINING HOOP AND REPLACE THE REAR TRACK BAR IF ANY ARE FOUND TO BE MIS-POSITIONED. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
January 11, 2010
(Campaign #: J38)
FRONT AIR BAG CRASH SENSOR FAILURE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2005-2006 DODGE CARAVAN, GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, KANSAS, KENTUCKY, MASSACHUSETTS, MAINE, MARYLAND, MICHIGAN, MINNESOTA, MISSOURI, NEBRASKA, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, NORTH DAKOTA, OHIO, PENNSYLVANIA, RHODE ISLAND, SOUTH DAKOTA, TENNESSEE, UTAH, VERMONT, VIRGINIA, WEST VIRGINIA, WISCONSIN, ALASKA AND THE DISTRICT OF COLUMBIA. THE FRONT CRASH SENSORS MAY CRACK UNDER CERTAIN ENVIRONMENTAL CONDITIONS AND ALLOW WATER TO ENTER INTO THE SENSOR. THIS CAN CAUSE THE SENSOR TO BECOME INOPERATIVE AND ILLUMINATE THE AIRBAG WARNING LIGHT. THESE SENSORS WERE ADDED TO ENHANCE THE PERFORMANCE OF THE AIRBAG SYSTEM IN CERTAIN FRONTAL CRASHES.
NHTSA ID: 10V008000
Component: AIR BAGS
# of Units Affected: 308,950
Consequence Summary:
IF THE FRONT CRASH SENSORS BECOME INOPERATIVE, THE DRIVER IS IMMEDIATELY ALERTED BY ILLUMINATION OF THE AIRBAG WARNING LIGHT AND THE VEHICLE SHOULD BE PROMPTLY SERVICED. UNTIL THE VEHICLE IS REPAIRED, THE AIRBAGS MAY NOT PROVIDE THE ENHANCED PROTECTION IN THE EVENT OF A CRASH.
Corrective Action:
CHRYSLER WILL REPLACE THE FRONT AIRBAG SENSORS WITH A NEW DESIGN. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY IMPROVEMENT CAMPAIGN WILL BEGIN DURING JUNE 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
January 11, 2010
(Campaign #: J37)
BRAKE BOOSTER INPUT ROD RETAINING CLIP
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2010 CHRYSLER SEBRING; DODGE AVENGER AND NITRO; JEEP LIBERTY, COMMANDER AND GRAND CHEROKEE; AND MODEL YEAR 2009-2010 DODGE RAM TRUCK. THESE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY FORMED OR MISSING BRAKE BOOSTER INPUT ROD RETAINING CLIP.
NHTSA ID: 10V009000
Component:
# of Units Affected: 20,045
Consequence Summary:
THIS COULD RESULT IN BRAKE FAILURE WITHOUT WARNING WHICH COULD CAUSE A CRASH.
Corrective Action:
CHRYSLER WILL REPLACE THE BRAKE BOOSTER INPUT ROD RETAINING CLIP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING FEBRUARY 2010. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Park Outside Advisory: No
Do not Drive Advisory: No
Popular Topics:
Find us
Copyright © Beautify Data LLC. All Rights Reserved.