Big Dog Motorcycles, LLC: Safety Recalls in 2006

Updated on March 19, 2026.

There were 5 safety recalls made by Big Dog Motorcycles, LLC in 2006. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

October 12, 2006

(Campaign #: NR (Not Reported))

PIVOT BOLT REPLACEMENT

ON CERTAIN MOTORCYCLES, THE LONG PIVOT BOLT MAY BEND OR BREAK DURING NORMAL OPERATION OF THE MOTORCYCLE.

NHTSA ID: 06V389000

Component:

# of Units Affected: 2,494

Consequence Summary:

THIS COULD POTENTIALLY CAUSE THE REAR FENDER TO ABRADE AGAINST THE REAR TIRE WHILE THE MOTORCYCLE IS BEING DRIVEN. THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.

Corrective Action:

DEALERS WILL REPLACE THE LONG PIVOT BOLT AND, IF NECESSARY, STRAIGHTEN THE REAR FRAME SIDE PANEL. THE SHORT LEFT SIDE PIVOT BOLT AND PIVOT SHAFT MAY ALSO BE REPLACED FREE OF CHARGE. THE RECALL BEGAN ON NOVEMBER 1, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

August 11, 2006

(Campaign #: NR (Not Reported))

ELECTRONIC HARNESS CONTROL (EHC) MODULE

ON CERTAIN MOTORCYCLES, THE ELECTRONIC HARNESS CONTROL (EHC) MODULE CAN FAIL RESULTING IN A TOTAL SHUT DOWN OF THE VEHICLE'S ELECTRONIC POWER.

NHTSA ID: 06V305000

Component:

# of Units Affected: 2,101

Consequence Summary:

THIS CONDITION COULD OCCUR WITHOUT ANY PRIOR WARNING AND COULD RESULT IN A CRASH.

Corrective Action:

DEALERS WILL REPLACE THE EHC MODULES FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 19, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

August 9, 2006

(Campaign #: NR (Not Reported))

IGNITION MODULE BATTERY TRAY

ON CERTAIN MOTORCYCLES, THE IGNITION MODULES ARE ORIENTED WITHIN THE BATTERY TRAY IN A WAY THAT MAKES THE IGNITION MODULE SUSCEPTIBLE TO VIBRATION.

NHTSA ID: 06V301000

Component: ELECTRICAL SYSTEM

# of Units Affected: 2,711

Consequence Summary:

THIS SUSCEPTIBILITY TO VIBRATION MAY CONTRIBUTE TO A STALLING CONDITION THAT COULD OCCUR WITHOUT ANY PRIOR WARNING AND RESULT IN A CRASH.

Corrective Action:

DEALERS WILL INSTALL A NEW IGNITION MODULE MOUNTING SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 25, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

April 14, 2006

(Campaign #: NR (Not Reported))

FRONT FENDER BRACKETS

ON CERTAIN MOTORCYCLES, THE FRONT FENDER BRACKETS COULD FAIL ALLOWING THE FRONT FENDER TO DETACH.

NHTSA ID: 06V122000

Component:

# of Units Affected: 364

Consequence Summary:

IF THIS CONDITION OCCURS, A CRASH COULD OCCUR WITHOUT ANY PRIOR WARNING.

Corrective Action:

DEALERS WILL REPLACE THE FRONT FENDER BRACKETS FREE OF CHARGE. (BIG DOG RECALLED CERTAIN BULLDOG MOTORCYCLES IN MAY 2005. BIG DOG REVISED THE REPAIR INSTRUCTIONS AND IS RECALLING ALL THE 2005 BULLDOG MOTORCYCLES. IF YOUR MOTORCYCLE WAS REPAIRED UNDER THE PREVIOUS CAMPAIGN, IT WILL NEED TO BE REMEDIED AGAIN.) THE RECALL BEGAN ON APRIL 24, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

January 25, 2006

(Campaign #: NR (Not Reported))

KICKSTAND SPRING

ON CERTAIN MOTORCYCLES, THE KICKSTAND SPRING MAY STRETCH AND DETACH FROM THE MOUNTING BRACKET OR THE KICKSTAND.

NHTSA ID: 06V019000

Component: STRUCTURE

# of Units Affected: 9,726

Consequence Summary:

THIS WILL ALLOW THE KICKSTAND TO DEPLOY INTO THE EXTENDED POSITION AND CAUSE A CRASH.

Corrective Action:

DEALERS WILL INSTALL A NEW KICKSTAND SPRING FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 17, 2006. OWNERS MAY CONTACT BIG DOG AT 316-267-9121.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details