AM GENERAL LLC: Safety Recalls in 1994

Updated on March 19, 2026.

There were 2 safety recalls made by AM GENERAL LLC in 1994. See the details of the recalls below.

You can also see similar information for other manufacturers.

Data Source: NHTSA.

See this for other years:

September 1, 1994

(Campaign #: NR (Not Reported))

FUEL:FUEL LINES:HOSES:NON-METALLIC

THE PASSENGER COMPARTMENT IS SEPARATED FROM THE ENGINE COMPARTMENT BY AN INSULATED ENGINE COVER. THE INSULATION INSIDE THIS COVER CAN RUB AGAINST THE FUEL RETURN HOSE RESULTING IN A FUEL LEAK. ADDITIONALLY, A WIRING HARNESS CAN ALSO WEAR THROUGH CAUSING INTERRUPTION TO SOME ELECTRICAL OPERATIONS, INCLUDING THE FUEL PUMP.

NHTSA ID: 94V162000

Component: FUEL SYSTEM, GASOLINE

# of Units Affected: 1,300

Consequence Summary:

FUEL LEAKING INSIDE THE ENGINE COMPARTMENT CAN RESULT IN A FIRE WHEN EXPOSED TO A SOURCE OF IGNITION. FAILURE OF THE ELECTRIC FUEL PUMP CAN CAUSE POOR PERFORMANCE AND POSSIBLE STALLING CREATING A ROAD HAZARD WHICH CAN RESULT IN AN ACCIDENT.

Corrective Action:

DEALERS WILL REPLACE THE RUBBER FUEL LINE HOSE WITH A SOLID STEEL LINES AND ROUTE THE LINE TO PROVIDE ONE INCH OF CLEARANCE TO THE COVER. ALSO, THE WIRING HARNESS COVER WILL BE REPLACED AND THE WIRING REROUTED TO GAIN SUFFICIENT CLEARANCE.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details

September 1, 1994

(Campaign #: NR (Not Reported))

FUEL: VEHICLE CRASH, CUT OFF SYSTEM (5-94)

THE OIL PRESSURE SWITCH WHICH CONTROLS THE POWER TO THE ELECTRIC FUEL PUMP CAN FAIL. FAILURE IS DUE TO A MISSING RUBBER SEAL BETWEEN THE SWITCH AND THE WIRING HARNESS. THE MISSING SEAL ALLOWS CONTAMINANTS TO ENTER THE SWITCH CAUSING IT TO FAIL IN THE OPEN OR CLOSED POSITION.

NHTSA ID: 94V164000

Component: FUEL SYSTEM, GASOLINE

# of Units Affected: 2,300

Consequence Summary:

IF THE SWITCH FAILS IN THE CLOSED POSITION, THE PUMP WILL CONTINUE TO RUN WHEN THE ENGINE IS OFF, DRAINING THE BATTERY. IF THE SWITCH FAILS IN THE OPEN POSITION IT WILL CAUSE POOR PERFORMANCE AND POSSIBLY STALLING.

Corrective Action:

DEALERS WILL INSPECT THE VEHICLES FOR THE PRESENCE OF THE SEAL. IF THE SEAL IS MISSING, THE SWITCH WILL BE REPLACED AND A NEW SEAL WILL BE INSTALLED.

Park Outside Advisory: No

Do not Drive Advisory: No

View Full Recall Details